Dataset Information

Novel strategy of using methyl esters as slow release methanol source during lipase expression by mut+ Pichia pastoris X33.

ABSTRACT: One of the major issues with heterologous production of proteins in Pichia pastoris X33 under AOX1 promoter is repeated methanol induction. To obviate repeated methanol induction, methyl esters were used as a slow release source of methanol in lipase expressing mut+ recombinant. Experimental design was based on the strategy that in presence of lipase, methyl esters can be hydrolysed to release their products as methanol and fatty acid. Hence, upon break down of methyl esters by lipase, first methanol will be used as a carbon source and inducer. Then P. pastoris can switch over to fatty acid as a carbon source for multiplication and biomass maintenance till further induction by methyl esters. We validated this strategy using recombinant P. pastoris expressing Lip A, Lip C from Trichosporon asahii and Lip11 from Yarrowia lipolytica. We found that the optimum lipase yield under repeated methanol induction after 120 h was 32866 U/L, 28271 U/L and 21978 U/L for Lip C, Lip A and Lip 11 respectively. In addition, we found that a single dose of methyl ester supported higher production than repeated methanol induction. Among various methyl esters tested, methyl oleate (0.5%) caused 1.2 fold higher yield for LipA and LipC and 1.4 fold for Lip11 after 120 h of induction. Sequential utilization of methanol and oleic acid by P. pastoris was observed and was supported by differential peroxisome proliferation studies by transmission electron microscopy. Our study identifies a novel strategy of using methyl esters as slow release methanol source during lipase expression.

SUBMITTER: Kumari A

PROVIDER: S-EPMC4149357 | biostudies-literature | 2014

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Novel strategy of using methyl esters as slow release methanol source during lipase expression by mut+ Pichia pastoris X33.

Kumari Arti A Gupta Rani R

PloS one 20140829 8

One of the major issues with heterologous production of proteins in Pichia pastoris X33 under AOX1 promoter is repeated methanol induction. To obviate repeated methanol induction, methyl esters were used as a slow release source of methanol in lipase expressing mut+ recombinant. Experimental design was based on the strategy that in presence of lipase, methyl esters can be hydrolysed to release their products as methanol and fatty acid. Hence, upon break down of methyl esters by lipase, first met ...[more]

PMID: 25170843

Similar Datasets

Project description:BACKGROUND: One of the main challenges for heterologous protein production by the methylotrophic yeast Pichia pastoris at large-scale is related to its high oxygen demand. A promising solution is a co-feeding strategy based on a methanol/sorbitol mixture during the induction phase. Nonetheless, a deep understanding of the cellular physiology and the regulation of the AOX1 promoter, used to govern heterologous protein production, during this co-feeding strategy is still scarce. RESULTS: Transient continuous cultures with a dilution rate of 0.023 h(-1) at 25°C were performed to quantitatively assess the benefits of a methanol/sorbitol co-feeding process with a Mut+ strain in which the pAOX1-lacZ construct served as a reporter gene. Cell growth and metabolism, including O2 consumption together with CO2 and heat production were analyzed with regard to a linear change of methanol fraction in the mixed feeding media. In addition, the regulation of the promoter AOX1 was investigated by means of ?-galactosidase measurements. Our results demonstrated that the cell-specific oxygen consumption (qO2) could be reduced by decreasing the methanol fraction in the feeding media. More interestingly, maximal ?-galactosidase cell-specific activity (>7500 Miller unit) and thus, optimal pAOX1 induction, was achieved and maintained in the range of 0.45?~?0.75 C-mol/C-mol of methanol fraction. In addition, the qO2 was reduced by 30% at most in those conditions. Based on a simplified metabolic network, metabolic flux analysis (MFA) was performed to quantify intracellular metabolic flux distributions during the transient continuous cultures, which further shed light on the advantages of methanol/sorbitol co-feeding process. Finally, our observations were further validated in fed-batch cultures. CONCLUSION: This study brings quantitative insight into the co-feeding process, which provides valuable data for the control of methanol/sorbitol co-feeding, aiming at enhancing biomass and heterologous protein productivities under given oxygen supply. According to our results, ?-galactosidase productivity could be improved about 40% using the optimally mixed feed.

Project description:?ACKGROUND: The methylotrophic yeast Pichia pastoris has become an important host organism for recombinant protein production and is able to use methanol as a sole carbon source. The methanol utilization pathway describes all the catalytic reactions, which happen during methanol metabolism. Despite the importance of certain key enzymes in this pathway, so far very little is known about possible effects of overexpressing either of these key enzymes on the overall energetic behavior, the productivity and the substrate uptake rate in P. pastoris strains.A fast and easy-to-do approach based on batch cultivations with methanol pulses was used to characterize different P. pastoris strains. A strain with MutS phenotype was found to be superior over a strain with Mut+ phenotype in both the volumetric productivity and the efficiency in expressing recombinant horseradish peroxidase C1A. Consequently, either of the enzymes dihydroxyacetone synthase, transketolase or formaldehyde dehydrogenase, which play key roles in the methanol utilization pathway, was co-overexpressed in MutS strains harboring either of the reporter enzymes horseradish peroxidase or Candida antarctica lipase B. Although the co-overexpression of these enzymes did not change the stoichiometric yields of the recombinant MutS strains, significant changes in the specific growth rate, the specific substrate uptake rate and the specific productivity were observed. Co-overexpression of dihydroxyacetone synthase yielded a 2- to 3-fold more efficient conversion of the substrate methanol into product, but also resulted in a reduced volumetric productivity. Co-overexpression of formaldehyde dehydrogenase resulted in a 2-fold more efficient conversion of the substrate into product and at least similar volumetric productivities compared to strains without an engineered methanol utilization pathway, and thus turned out to be a valuable strategy to improve recombinant protein production.Co-overexpressing enzymes of the methanol utilization pathway significantly affected the specific growth rate, the methanol uptake and the specific productivity of recombinant P. pastoris MutS strains. A recently developed methodology to determine strain specific parameters based on dynamic batch cultivations proved to be a valuable tool for fast strain characterization and thus early process development.

Project description:BackgroundInducible high-level expression is favoured for recombinant protein production in Pichia pastoris. Therefore, novel regulated promoters are desired, ideally repressing heterologous gene expression during initial growth and enabling it in the production phase. In a typical large scale fed-batch culture repression is desired during the batch phase where cells grow on a surplus of e.g. glycerol, while heterologous gene expression should be active in the feed phase under carbon (e.g. glucose) limitation.ResultsDNA microarray analysis of P. pastoris wild type cells growing in glycerol-based batch and glucose-based fed batch was used for the identification of genes with both, strong repression on glycerol and high-level expression in the feed phase. Six novel glucose-limit inducible promoters were successfully applied to express the intracellular reporter eGFP. The highest expression levels together with strong repression in pre-culture were achieved with the novel promoters P(G1) and P(G6). Human serum albumin (HSA) was used to characterize the promoters with an industrially relevant secreted protein. A P(G1) clone with two gene copies reached about 230% of the biomass specific HSA titer in glucose-based fed batch fermentation compared to a P(GAP) clone with identical gene copy number, while P(G6) only achieved 39%. Two clones each carrying eleven gene copies, expressing HSA under control of P(G1) and P(G6) respectively were generated by post-transformational vector amplification. They produced about 1.0 and 0.7 g L(-1) HSA respectively in equal fed batch processes. The suitability in production processes was also verified with HyHEL antibody Fab fragment for P(G1) and with porcine carboxypeptidase B for P(G6). Moreover, the molecular function of the gene under the control of P(G1) was determined to encode a high-affinity glucose transporter and named GTH1.ConclusionsA set of novel regulated promoters, enabling induction without methanol, was successfully identified by using DNA microarrays and shown to be suitable for high level expression of recombinant proteins in glucose-based protein production processes.

Dataset Information

Novel strategy of using methyl esters as slow release methanol source during lipase expression by mut+ Pichia pastoris X33.

Publications

Novel strategy of using methyl esters as slow release methanol source during lipase expression by mut+ Pichia pastoris X33.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure