Dataset Information

Stable high-level expression of factor VIII in Chinese hamster ovary cells in improved elongation factor-1 alpha-based system.

ABSTRACT: Recombinant factor VIII (FVIII), used for haemophilia A therapy, is one of the most challenging among the therapeutic proteins produced in heterologous expression systems. Deletion variant of FVIII, in which the entire domain B is replaced by a short linker peptide, was approved for medical use. Efficacy and safety of this FVIII deletion variant are similar to full-length FVIII preparations while the level of production in CHO cells is substantially higher. Typical levels of productivity for CHO cell lines producing deletion variant FVIII-BDD SQ, described elsewhere, are 0.5-2 IU/ml, corresponding to the concentration of FVIII of about 0.2 ?g/ml. Using standard vectors based on the cytomegalovirus promoter (CMV) and the dihydrofolate reductase cDNA we have previously obtained the cell line secreting 0.5 IU/ml of FVIII-BDD, which roughly corresponds to the previously published data.An expression system based on CHO genomic sequences including CHO-EEF1A promoter and Epstein-Barr virus terminal repeat fragment allowed us to achieve 80-fold increase in the production level as compared with the conventional expression system based on the CMV promoter. Immediately after the primary selection FVIII -producing cells secreted 5-10 IU/ml of FVIII-BDD, and after multi-stage methotrexate-driven amplification a stable clonal line 11A4H was selected, secreting 39 IU/ml of FVIII-BDD in the simple batch culturing conditions, which considerably exceeds known indicators for industrial producers of this protein. In contrast to other FVIII-BDD producing lines 11A4H accumulates low proportion of the secreted FVIII on the membrane. Its productivity may be further increased approximately two-fold by adding sodium butyrate and butylated hydroxyanisol to the culture medium. A five-stage purification process for the factor VIII was employed. It allowed isolation of the intact FVIII-BDD as was confirmed by mass spectrometry. Purified FVIII-BDD has a specific activity of 11,000 IU/mg, similar to known recombinant FVIII drugs.The recombinant FVIII-BDD was produced in CHO cells without addition of any animal-derived materials, purified and characterized. Novel genetic constructions for the expression of heterologous proteins combined with optimized cultivation method allowed to obtain the secretion level of biologically active recombinant FVIII increased by almost ten times as compared with the previously published analogues.

SUBMITTER: Orlova NA

PROVIDER: S-EPMC5366130 | biostudies-literature | 2017 Mar

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Stable high-level expression of factor VIII in Chinese hamster ovary cells in improved elongation factor-1 alpha-based system.

Orlova Nadezhda A NA Kovnir Sergey V SV Gabibov Alexandre G AG Vorobiev Ivan I II

BMC biotechnology 20170324 1

<h4>Background</h4>Recombinant factor VIII (FVIII), used for haemophilia A therapy, is one of the most challenging among the therapeutic proteins produced in heterologous expression systems. Deletion variant of FVIII, in which the entire domain B is replaced by a short linker peptide, was approved for medical use. Efficacy and safety of this FVIII deletion variant are similar to full-length FVIII preparations while the level of production in CHO cells is substantially higher. Typical levels of p ...[more]

PMID: 28340620

Similar Datasets

Project description:BACKGROUND: Establishing highly productive clonal cell lines with constant productivity over 2-3 months of continuous culture remains a tedious task requiring the screening of tens of thousands of clonal colonies. In addition, long-term cultivation of many candidate lines derived in the absence of drug selection pressure is necessary. Expression vectors based on the elongation factor-1 alpha (EEF1A) gene and the dihydrofolate reductase (DHFR) selection marker (with separate promoters) can be used to obtain highly productive populations of stably transfected cells in the selection medium, but they have not been tested for their ability to support target gene amplification under gradually increasing methotrexate pressure. RESULTS: We have modified EEF1A-based vectors by linking the DHFR selection marker to the target gene in the bicistronic RNA, shortening the overall plasmid size, and adding an Epstein-Barr virus terminal repeat fragment (EBVTR) element. Presence of the EBVTR element increased the rate of stable transfection by the plasmid by 24 times that of the EBVTR-minus control and improved the rate of methotrexate-driven gene amplification. The mean expression level of the enhanced green fluorescent protein (eGFP) used herein as a model protein, increased up to eight-fold using a single round of amplification in the case of adherent colonies formation and up to 4.5-fold in the case of suspension polyclonal cultures. Several eGFP-expressing cell populations produced using vectors with antibiotic resistance markers instead of the DHFR marker were compared with each other. Stable transfection of Chinese hamster ovary (CHO) DG44 cells by the p1.2-Hygro-eGFP plasmid (containing a hygromycin resistance marker) generated highest eGFP expression levels of up to 8.9% of the total cytoplasmic protein, with less than 5% of the cell population being eGFP-negative. CONCLUSIONS: The p1.1 vector was very effective for stable transfection of CHO cells and capable of rapid MTX-driven target gene amplification, while p1.2-Hygro achieved similar eGFP expression levels as p1.1. The set of vectors we have developed should speed-up the process of generating highly productive clonal cell lines while substantially decreasing the associated experimental effort.

Project description:BackgroundThe Chinese hamster ovary (CHO) cell line is the main host for the high-titer production of therapeutic and diagnostic proteins in the biopharmaceutical industry. In most cases, plasmids for efficient protein expression in CHO cells are based on the cytomegalovirus (CMV) promoter. The autologous Chinese hamster eukaryotic translation elongation factor 1α (EEF1A1) promoter is a viable alternative to the CMV promoter in industrial applications. The EEF1A1 promoter and its surrounding DNA regions proved to be effective at maintaining high-level and stable expression of recombinant proteins in CHO cells. EEF1A1-based plasmids' large size can lead to low transfection efficiency and hamper target gene amplification. We hypothesized that an efficient EEF1A1-based expression vector with a long terminal repeat fragment from the Epstein-Barr virus (EBVTR) could be truncated without affecting promoter strength or the long-term stability of target gene expression.MethodsWe made a series of deletions in the downstream flanking region of the EEF1A1 gene, and then in its upstream flanking region. The resulting plasmids, which coded for the enhanced green fluorescent protein (eGFP), were tested for the level of eGFP expression in the populations of stably transfected CHO DG44 cells and the stability of eGFP expression in the long-term culture in the absence of selection agents.ResultsIt was shown that in the presence of the EBVTR fragment, the entire downstream flanking region of the EEF1A1 gene could be excluded from the plasmid vector. Shortening of the upstream flanking region of the EEF1A1 gene to a length of 2.5 kbp also had no significant effect on the level of eGFP expression or long-term stability. The EBVTR fragment significantly increased expression stability for both the CMV and EEF1A1 promoter-based plasmids, and the expression level drop during the two-month culture was more significant for both CMV promoter-based plasmids.ConclusionTarget protein expression stability for the truncated plasmid, based on the EEF1A1 gene and EBVTR fragment, is sufficient for common biopharmaceutical applications, making these plasmid vectors a viable alternative to conventional CMV promoter-based vectors.

Dataset Information

Stable high-level expression of factor VIII in Chinese hamster ovary cells in improved elongation factor-1 alpha-based system.

Publications

Stable high-level expression of factor VIII in Chinese hamster ovary cells in improved elongation factor-1 alpha-based system.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure

Tweets