Dataset Information

Evaluation of in vitro ruminal fermentation of ensiled fruit byproducts and their potential for feed use.

ABSTRACT: OBJECTIVE:Ensiling of tannin-rich fruit byproducts (FB) involves quantitative and qualitative changes in the tannins, which would consequently change the rumen fermentation characteristics. This study aimed to evaluate whether ensiled FBs are effective in mitigating methane emission from ruminants by conducting in vitro assessments. METHODS:Fruit byproducts (grape pomace, wild grape pomace, and persimmon skin) were collected and subjected to four-week ensiling by Lactobacillus buchneri inoculant. A defined feed component with or without FB samples (both fresh and ensiled material) were subjected to in vitro anaerobic culturing using rumen fluid sampled from beef cattle, and the fermentation parameters and microbial populations were monitored. RESULTS:Reduced methane production and a proportional change in total volatile fatty acids (especially enhanced propionate proportion) was noted in bottles containing the FBs compared with that in the control (without FB). In addition, we found lower gene copy number of archaeal 16S rRNA and considerably higher levels of one of the major fibrolytic bacteria (Fibrobacter succinogenes) in the bottles containing FBs than in the control, particularly, when it was included in a forage-based feed. However, in the following cultivation experiment, we observed that FBs failed to exhibit a significant difference in methane production with or without polyethylene glycol, implying that tannins in the FBs may not be responsible for the mitigation of methane generation. CONCLUSION:The results of the in vitro cultivation experiments indicated that not only the composition but also ensiling of FBs affected rumen fermentation patterns and the degree of methane generation. This is primarily because of the compositional changes in the fibrous fraction during ensiling as well as the presence of readily fermented substrates, whereas tannins in these FBs seemed to have little effect on the ruminal fermentation kinetics.

SUBMITTER: Mousa SA

PROVIDER: S-EPMC6325409 | biostudies-literature | 2019 Jan

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Evaluation of in vitro ruminal fermentation of ensiled fruit byproducts and their potential for feed use.

Mousa Shimaa A SA Malik Pradeep K PK Kolte Atul P AP Bhatta Raghavendra R Kasuga Shigemitsu S Uyeno Yutaka Y

Asian-Australasian journal of animal sciences 20180531 1

<h4>Objective</h4>Ensiling of tannin-rich fruit byproducts (FB) involves quantitative and qualitative changes in the tannins, which would consequently change the rumen fermentation characteristics. This study aimed to evaluate whether ensiled FBs are effective in mitigating methane emission from ruminants by conducting in vitro assessments.<h4>Methods</h4>Fruit byproducts (grape pomace, wild grape pomace, and persimmon skin) were collected and subjected to four-week ensiling by Lactobacillus buc ...[more]

PMID: 29879816

Similar Datasets

Project description:Much research on animal feed has focused on finding alternative feed ingredients that can replace conventional ones (e.g., grains and beans) to reduce feed costs. The objective of this study was to evaluate the economic, as well as nutritional value of spent coffee grounds (SCG) and Japanese mugwort (Artemisia princeps) residues (APR) as alternative feed ingredients for ruminants. We also investigated whether pre-fermentation using Lactobacillus spp. was a feasible way to increase the feed value of these by-products. Chemical analyses and an in vitro study were conducted for SCG, APR, and their pre-fermented forms. All the experimental diets for in vitro ruminal fermentation were formulated to contain a similar composition of crude protein, neutral detergent fiber and total digestible nutrients at 1x maintenance feed intake based on the dairy National Research Council (NRC). The control diet was composed of ryegrass, corn, soybean meal, whereas the treatments consisted of SCG, SCG fermented with Lactobacillus spp. (FSCG), APR, and its fermented form (FAPR). The treatment diets replaced 100 g/kg dry matter (DM) of the feed ingredients in the control. Costs were lower for the all treatments, except FAPR, than that of the control. After 24-h incubation, the NDF digestibility of the diets containing SCG and its fermented form were significantly lower than those of the other diets (P < 0.01); pre-fermentation tended to increase NDF digestibility (P = 0.07), especially for APR. Supplementation of SCG significantly decreased total gas production (ml/g DM) after 24-h fermentation in comparison with the control (P < 0.05); however, there were no significant differences between the control and the SCG or the APR diets in total gas production, as expressed per Korean Won (KRW). Diets supplemented with SCG or FSCG tended to have a higher total volatile fatty acid (VFA) concentration, expressed as per KRW, compared with the control (P = 0.06). Conversely, the fermentation process of SCG and APR significantly decreased total gas production and VFA production as expressed per KRW (P < 0.05). Because of their nutrient composition and relatively lower cost, we concluded that SCG and APR could be used as alternative feed sources, replacing conventional feed ingredients. However, pre-fermentation of agricultural by-products, such as SCG and APR, may be inappropriate for improving their nutritive considering the increase in production costs.

Project description:Persimmon skin (PS), while representing an attractive feed source, requires an appropriate preservation procedure to increase its shelf life. We assessed the fermentation quality, in vitro ruminal incubation, and intake of persimmon skin silage ensiled with different dry absorbents. We prepared the silage on a table scale (Experiment 1) and evaluated five different mixtures: PS without an additive, PS plus Lactobacillus buchneri inoculum (LB), and PS plus LB plus each of the absorbents kraft pulp, wheat bran, or beet pulp. We opened the laboratory bags, kept at 25 °C, at 0, 14, 28, and 60 days for fermentation quality and chemical analysis (n = 3 for each measurement). Further, with an in vitro rumen simulated cultivation study (Experiment 2), we evaluated the fermentation pattern of PS with a mixture of two absorbents (kraft pulp and wheat bran) either raw (no fermentation) or ensiled (n = 4 for each treatment). Finally, we conducted an in vivo experiment using six dry ewes assigned based on their body weight to two experimental groups in a crossover design of two periods (Experiment 3). We fed a control group a 100% basal diet (tall fescue hay and concentrate mixture) and ensiled PS (PSS) group, a 20% dry matter substitution of tall fescue with PS silage mixed with kraft pulp as the sole absorbent. The results of Experiment 1 show, regardless of the absorbents used, the effluent volume of the lab bags was lower in absorbent-treated groups (p < 0.001). In Experiment 2, the condition of the PS with absorbents (raw or ensiled) did not affect the total gas production (p > 0.05), but we observed an increased propionate proportion in PSS with absorbents compared to basal diet (p = 0.019). The proportion of methane to the total gas in PSS group was considerably reduced compared with that in the other groups (p < 0.001). As we did this incubation study with a single run, a more detailed evaluation in the future would verify these observations. In the animal trial (Experiment 3), dry matter intake was similar between groups (p > 0.05), but ewes spent a shorter time eating in the PSS-fed group (p = 0.011). Here we present the practical use of PSS as part of ruminant feed in which dry absorbents prevented dry matter loss.

Project description:This study was aimed to evaluate the effects of Camelina sativa oil (CO) on fermentation kinetics and methane (CH4) production in rations with different roughage (R) to concentrate (C) ratios. Three total mixed rations (TMRs) were used as substrates (R70:C30, R50:C50, and R30:C70) supplemented with different levels of CO (0, 2, 4, 6, and 8% on dry matter basis) in an in vitro batch culture system. The enteric CH4 production was determined at different times of incubation while fermentation parameters were measured at the end of incubation. Results revealed that CO significantly decreased (P < 0.05) CH4 production at 48 h in medium (R50:C50) and low- (R30:C70) roughage diets than control. Camelina oil at all levels significantly (P < 0.05) affected ammonia nitrogen (NH3-N) and microbial protein (MCP) in all rations. Propionate concentration was increased by supplementing 8% CO to R70:C30 TMR, but it decreased with increasing levels of CO for low- and medium-roughage diets. Acetate concentration was significantly (P < 0.05) higher at 4% CO supplementation, but it decreased with 8% CO level in R30:C70 TMR. For all rations, CO decreased (P < 0.001) total bacteria, protozoa, and methanogens. Total fungi counts were affected by CO in all rations, especially with a 6% level in two rations (R30:C70 and R50:C50) and 8% level with high-roughage ration (R70:C30). Supplementation of CO in medium-roughage ration (R50:C50) showed a linear (P < 0.05) decrease in bacterial richness and evenness indices along with Shannon diversity as compared to the control. Moreover, CO also increased Firmicutes to Bacteroidetes ratio in all TMRs more effectively at higher levels. Camelina oil also affected the relative abundance of Prevotella in both low- and medium-roughage diets while increasing the abundance of Ruminobacter and Pseudobutyrivibrio. The present study concluded that CO enhanced fermentation kinetics while decreasing enteric in vitro CH4 production from fibrous diets. Thus, it may be considered as a potentially effective and environmentally friendly way of mitigating CH4 emission from livestock.

Project description:Indiscriminate use of antibiotics can result in antibiotic residues in animal products; thus, plant compounds may be better alternative sources for mitigating methane (CH4) production. An in vitro screening experiment was conducted to evaluate the potential application of 152 dry methanolic or ethanolic extracts from 137 plant species distributed in East Asian countries as anti-methanogenic additives in ruminant feed. The experimental material consisted of 200 mg total mixed ration, 20 mg plant extract, and 30 mL diluted ruminal fluid-buffer mixture in 60 mL serum bottles that were sealed with rubber stoppers and incubated at 39 °C for 24 h. Among the tested extracts, eight extracts decreased CH4 production by >20%, compared to the corresponding controls: stems of Vitex negundo var. incisa, stems of Amelanchier asiatica, fruit of Reynoutria sachalinensis, seeds of Tribulus terrestris, seeds of Pharbitis nil, leaves of Alnus japonica, stem and bark of Carpinus tschonoskii, and stems of Acer truncatum. A confirmation assay of the eight plant extracts at a dosage of 10 mg with four replications repeated on 3 different days revealed that the extracts decreased CH4 concentration in the total gas (7-15%) and total CH4 production (17-37%), compared to the control. This is the first report to identify the anti-methanogenic activities of eight potential plant extracts. All extracts decreased ammonia (NH3-N) concentrations. Negative effects on total gas and volatile fatty acid (VFA) production were also noted for all extracts that were rich in hydrolysable tannins and total saponins or fatty acids. The underlying modes of action differed among plants: extracts from P. nil, V. negundo var. incisa, A. asiatica, and R. sachalinensis resulted in a decrease in total methanogen or the protozoan population (p < 0.05) but extracts from other plants did not. Furthermore, extracts from P. nil decreased the population of total protozoa and increased the proportion of propionate among VFAs (p < 0.05). Identifying bioactive compounds in seeds of P. nil by gas chromatography-mass spectrometry analysis revealed enrichment of linoleic acid (18:2). Overall, seeds of P. nil could be a possible alternative to ionophores or oil seeds to mitigate ruminal CH4 production.

Project description:The present study evaluated the effects of 4 typical subtropical forages on ruminal microbial community composition to formulate a better diet for buffalo. Corn straw silage, elephant grass, cassava residues and sugarcane tail silage were used as substrates for in vitro fermentation. Eight replicates were set up for every substrate, and fermentation was carried out in a 100-mL glass syringe, using buffalo rumen inoculum. Every replicate was anaerobically dispensed with 10 mL of rumen inoculum, 20 mL of McDougall's buffer and 200 mg of dried substrate, and placed in a water bath at 39 °C. Gas production was recorded at 0, 2, 6, 12, 24, 36, 48 and 72 h of incubation. After 24 h, fermentation was ceased for 4 replicates and samples were collected. Volatile fatty acids (VFA) concentrations were measured using gas chromatography. Microbial populations were quantified using quantitative real-time PCR (qRT-PCR), and microbial community was analyzed using high throughput sequencing technology. The results showed, cassava residues as substrate had the highest gas production, acetate, propionate and total VFA concentrations (P < 0.05), and corn straw silage had the lowest acetate:propionate ratio (P < 0.05). The lowest numbers of fungi, Ruminococcus albus and Fibrobacter succinogenes, and the highest number of protozoa were observed with cassava residues (P < 0.05). The least abundances of bacterial phyla Firmicutes, Bacteroidetes and genus Prevotella, and substantially higher abundance of phylum proteobacteria (56%) and genus Succinivibrio (52%) were observed with cassava residues. The most abundances of Methanobrevibacter gottschalkii and Entodinium were observed with cassava residues. Spearman's correlations analysis showed, Succinivibrio had strong positive correlations with propionate, butyrate, Metadinium and M. gottschalkii, indicating fermentation products were related to microbial community. In conclusion, incubation with cassava residues resulted in lower number of fiber degrading microbes but higher protozoal population because of its low fiber contents. The microbial community was highly altered by in vitro incubation with cassava residues, whereas remained similar for the other 3 high fiber containing substrates.

Project description:BackgroundThe awareness of environmental and socio-economic impacts caused by greenhouse gas emissions from the livestock sector leverages the adoption of strategies to counteract it. Feed supplements can play an important role in the reduction of the main greenhouse gas produced by ruminants-methane (CH4). In this context, this study aims to assess the effect of two biochar sources and inclusion levels on rumen fermentation parameters in vitro.MethodsTwo sources of biochar (agro-forestry residues, AFB, and potato peel, PPB) were added at two levels (5 and 10%, dry matter (DM) basis) to two basal substrates (haylage and corn silage) and incubated 24-h with rumen inocula to assess the effects on CH4 production and main rumen fermentation parameters in vitro.ResultsAFB and PPB were obtained at different carbonization conditions resulting in different apparent surface areas, ash content, pH at the point of zero charge (pHpzc), and elemental analysis. Relative to control (0% biochar), biochar supplementation kept unaffected total gas production and yield (mL and mL/g DM, p = 0.140 and p = 0.240, respectively) and fermentation pH (p = 0.666), increased CH4production and yield (mL and mL/g DM, respectively, p = 0.001) and ammonia-N (NH3-N, p = 0.040), and decreased total volatile fatty acids (VFA) production (p < 0.001) and H2 generated and consumed (p ≤ 0.001). Biochar sources and inclusion levels had no negative effect on most of the fermentation parameters and efficiency. Acetic:propionic acid ratio (p = 0.048) and H2 consumed (p = 0.019) were lower with AFB inclusion when compared to PPB. Biochar inclusion at 10% reduced H2 consumed (p < 0.001) and tended to reduce total gas production (p = 0.055). Total VFA production (p = 0.019), acetic acid proportion (p = 0.011) and H2 generated (p = 0.048) were the lowest with AFB supplemented at 10%, no differences being observed among the other treatments. The basal substrate affected most fermentation parameters independently of biochar source and level used.DiscussionBiochar supplementation increased NH3-N content, iso-butyric, iso-valeric and valeric acid proportions, and decreased VFA production suggesting a reduced energy supply for microbial growth, higher proteolysis and deamination of substrate N, and a decrease of NH3-N incorporation into microbial protein. No interaction was found between substrate and biochar source or level on any of the parameters measured. Although AFB and PPB had different textural and compositional characteristics, their effects on the rumen fermentation parameters were similar, the only observed effects being due to AFB included at 10%. Biochar supplementation promoted CH4 production regardless of the source and inclusion level, suggesting that there may be other effects beyond biomass and temperature of production of biochar, highlighting the need to consider other characteristics to better identify the mechanism by which biochar may influence CH4 production.

Project description:The objective of this study was to evaluate the changes in the ruminal fermentation, epithelium-associated microbiota, and ruminal epithelial barrier function in response to severe feed restriction (SFR) in pregnant ewes. Sixteen pregnant ewes (108 d of gestation) were randomly blocked and assigned to 1 of 2 treatments: control (CON, n = 8) and SFR (n = 8). Ewes were fed a common diet with a 60:40 forage to concentrate ratio for 7-d baseline period followed by a SFR challenge period. Ewes on the SFR treatment were restricted to 30% of the base for 15 d. At the end of the experimental period, all animals were slaughtered and then ruminal contents and ruminal epithelial tissue were collected. Results showed that ruminal pH was greater in SFR group (P = 0.040) compared with CON group, while SFR decreased (P < 0.05) the concentrations of ruminal acetate, propionate, butyrate, and total volatile fatty acid. A plot of principal coordinate analysis and analysis of molecular variance revealed that the composition of ruminal epithelial bacterial communities in the CON group was distinct from that of the ruminal epithelial microbiome in the SFR animals. At the genus level, SFR increased the abundance of unclassified Neisseriaceae, Comamonas, and Papillibacter, and decreased the proportion of Howardella, Desulfobulbus, and Suttonella (P < 0.05) compared with CON group. The metagenome of ruminal epithelium-associated microbiota predicted by PICRUSt revealed that the SFR significantly affected 14 metabolic pathways, and 9 were significantly enriched in the SFR group. In particular, SFR markedly increased relative abundances of dominant gene families involved in amino acid metabolism (P = 0.003), cellular processes and signaling (P = 0.021), and lipid metabolism (P = 0.001). The real-time PCR results showed SFR decreased the mRNA expression of IL-10 (P = 0.003) and upregulated the mRNA expression of IL-6 (P = 0.003) and TLR4 (P = 0.021). The mRNA expression of Claudin-1 (P = 0.001) and ZO-1 (P = 0.009) were lower in the SFR group compared with the CON group. Generally, our data suggest that SFR decreased most ruminal fermentation parameters, altered the composition of rumen epithelium-associated microbiota, and compromised the barrier function of rumen epithelium. These findings are of great importance for understanding the alteration in the rumen function following SFR in pregnant ewes.

Project description:This study investigated the effects of ensiled mulberry leaves (EML) and sun-dried mulberry fruit pomace (SMFP) on the ruminal bacterial and archaeal community composition of finishing steers. Corn grain- and cotton meal-based concentrate was partially replaced with EML or SMFP. The diets had similar crude protein (CP), neutral detergent fiber (NDF), and metabolizable energy. Following the feeding trial, the steers were slaughtered and ruminal liquid samples were collected to study the ruminal microbiome. Extraction of DNA, amplification of the V4 region of the 16S rRNA gene, and Illumina MiSeq pyrosequencing were performed for each sample. Following sequence de-noising, chimera checking, and quality trimming, an average of 209,610 sequences were generated per sample. Quantitative real-time PCR was performed to examine the selected bacterial species in the rumen. Our results showed that the predominant phyla were Bacteroidetes (43.90%), Firmicutes (39.06%), Proteobacteria (4.31%), and Tenericutes (2.04%), and the predominant genera included Prevotella (13.82%), Ruminococcus (2.51%), Butyrivibrio (2.38%), and Succiniclasticum (2.26%). Compared to the control group, EML and SMFP groups had a higher abundance of total bacteria (p < 0.001); however, the bacterial community composition was similar among the three groups. At the phylum level, there were no significant differences in Firmicutes (p = 0.7932), Bacteroidetes (p = 0.2330), Tenericutes (p = 0.2811), or Proteobacteria (p = 0.0680) levels among the three groups; however, Fibrobacteres decreased in EML (p = 0.0431). At the genus level, there were no differences in Prevotella (p = 0.4280), Ruminococcus (p = 0.2639), Butyrivibrio (p = 0.4433), or Succiniclasticum (p = 0.0431) levels among the groups. Additionally, the dietary treatments had no significant effects on the archaeal community composition in the rumen. Therefore, EML and SMFP supplementation had no significant effects on the ruminal bacterial or archaeal community composition of finishing steers.

Project description:The economy of biorefineries is influenced not only by biofuel production from carbohydrates but also by the production of valuable compounds from largely underutilized industrial residues. Currently, the demand for many chemicals that could be made in a biorefinery, such as succinic acid (SA), medium-chain fatty acids (MCFAs), and lactic acid (LA), is fulfilled using petroleum, palm oil, or pure carbohydrates as raw materials, respectively. Thin stillage (TS), the residual liquid material following distillation of ethanol, is an underutilized coproduct from the starch biofuel industry. This carbon-rich material has the potential for chemical upgrading by microorganisms. Here, we explored the formation of different fermentation products by microbial communities grown on TS using different bioreactor conditions. At the baseline operational condition (6-day retention time, pH 5.5, 35°C), we observed a mixture of MCFAs as the principal fermentation products. Operation of a bioreactor with a 1-day retention time induced an increase in SA production, and a temperature increase to 55°C resulted in the accumulation of lactic and propionic acids. In addition, a reactor operated with a 1-day retention time at 55°C conditions resulted in LA accumulation as the main fermentation product. The prominent members of the microbial community in each reactor were assessed by 16S rRNA gene amplicon sequencing and phylogenetic analysis. Under all operating conditions, members of the Lactobacillaceae family within Firmicutes and the Acetobacteraceae family within Proteobacteria were ubiquitous. Members of the Prevotellaceae family within Bacteroidetes and Lachnospiraceae family within the Clostridiales order of Firmicutes were mostly abundant at 35°C and not abundant in the microbial communities of the TS reactors incubated at 55°C. The ability to adjust bioreactor operating conditions to select for microbial communities with different fermentation product profiles offers new strategies to explore and compare potentially valuable fermentation products from TS and allows industries the flexibility to adapt and switch chemical production based on market prices and demands.

Dataset Information

Evaluation of in vitro ruminal fermentation of ensiled fruit byproducts and their potential for feed use.

Publications

Evaluation of in vitro ruminal fermentation of ensiled fruit byproducts and their potential for feed use.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure