Dataset Information

Acetate formation during recombinant protein production in Escherichia coli K-12 with an elevated NAD(H) pool.

ABSTRACT: Acetate formation is a disadvantage in the use of Escherichia coli for recombinant protein production, and many studies have focused on optimizing fermentation processes or altering metabolism to eliminate acetate accumulation. In this study, E. coli MEC697 (MG1655 nadR nudC mazG) maintained a larger pool of NAD(H) compared to the wild-type control, and also accumulated lower concentrations of acetate when grown in batch culture on glucose. In steady-state cultures, the elevated total NAD(H) found in MEC697 delayed the threshold dilution rate for acetate formation to a growth rate of 0.27 h-1. Batch and fed-batch processes using MEC697 were examined for the production of ?-galactosidase as a model recombinant protein. Fed-batch culture of MEC697/pTrc99A-lacZ compared to MG1655/pTrc99A-lacZ at a growth rate of 0.22 h-1 showed only a modest increase of protein formation. However, 1 L batch growth of MEC697/pTrc99A-lacZ resulted in 50% lower acetate formation compared to MG1655/pTrc99A-lacZ and a two-fold increase in recombinant protein production.

SUBMITTER: Han Q

PROVIDER: S-EPMC6999358 | biostudies-literature | 2019 Nov

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Acetate formation during recombinant protein production in Escherichia coli K-12 with an elevated NAD(H) pool.

Han Qi Q Eiteman Mark A MA

Engineering in life sciences 20190908 11

Acetate formation is a disadvantage in the use of Escherichia coli for recombinant protein production, and many studies have focused on optimizing fermentation processes or altering metabolism to eliminate acetate accumulation. In this study, E. coli MEC697 (MG1655 nadR nudC mazG) maintained a larger pool of NAD(H) compared to the wild-type control, and also accumulated lower concentrations of acetate when grown in batch culture on glucose. In steady-state cultures, the elev ...[more]

PMID: 32624970

Similar Datasets

Project description:BackgroundEthyl acetate (C4H8O2) and hydrogen (H2) are industrially relevant compounds that preferably are produced via sustainable, non-petrochemical production processes. Both compounds are volatile and can be produced by Escherichia coli before. However, relatively low yields for hydrogen are obtained and a mix of by-products renders the sole production of hydrogen by micro-organisms unfeasible. High yields for ethyl acetate have been achieved, but accumulation of formate remained an undesired but inevitable obstacle. Coupling ethyl acetate production to the conversion of formate into H2 may offer an interesting solution to both drawbacks. Ethyl acetate production requires equimolar amounts of ethanol and acetyl-CoA, which enables a redox neutral fermentation, without the need for production of by-products, other than hydrogen and CO2.ResultsWe engineered Escherichia coli towards improved conversion of formate into H2 and CO2 by inactivating the formate hydrogen lyase repressor (hycA), both uptake hydrogenases (hyaAB, hybBC) and/or overexpressing the hydrogen formate lyase activator (fhlA), in an acetate kinase (ackA) and lactate dehydrogenase (ldhA)-deficient background strain. Initially 10 strains, with increasing number of modifications were evaluated in anaerobic serum bottles with respect to growth. Four reference strains ΔldhAΔackA, ΔldhAΔackA p3-fhlA, ΔldhAΔackAΔhycAΔhyaABΔhybBC and ΔldhAΔackAΔhycAΔhyaABΔhybBC p3-fhlA were further equipped with a plasmid carrying the heterologous ethanol acyltransferase (Eat1) from Wickerhamomyces anomalus and analyzed with respect to their ethyl acetate and hydrogen co-production capacity. Anaerobic co-production of hydrogen and ethyl acetate via Eat1 was achieved in 1.5-L pH-controlled bioreactors. The cultivation was performed at 30 °C in modified M9 medium with glucose as the sole carbon source. Anaerobic conditions and gas stripping were established by supplying N2 gas.ConclusionsWe showed that the engineered strains co-produced ethyl acetate and hydrogen to yields exceeding 70% of the pathway maximum for ethyl acetate and hydrogen, and propose in situ product removal via gas stripping as efficient technique to isolate the products of interest.

Project description:The ability to control the synthesis of products in the absence of cell division remains an attractive alternative for the optimization of microbial processes. If this could be achieved, it would dramatically expand the productivity of many microbial processes by increasing product synthesis in the absence of an increase in cell mass. In the present work we have looked at the factors involved in the design of a host where the fluxes would be channeled towards product formation rather than biomass synthesis. To identify the genes responsible for diverting the metabolic flux specifically towards product formation we have used for this study is quiescent-cell (Q-cell) expression system, in which a plasmid-encoded protein is expressed in nongrowing but metabolically active cells. These cells channel the metabolic flux towards recombinant protein production and therefore the specific product yield per unit biomass is significantly higher. Indole which is previously known to be a signalling molecule is here used as an inducer of Quiescence. E.coli L-Asparaginase is used as a model protein in this work. Fed batch cultures were carried out in Sartorius BIOSTAT B plus 5liter bioreactor. The data acquisition was done with the MFCS Shell software (version) provided with the bioreactor. The Sartorius BIOSTAT B plus had proportional integral derivative-based control loops for temperature, pH, antifoam, and dissolved-oxygen (DO) regulation. The culture was grown in a batch mode till 10-12 OD (µ=0.5) and then the feed was attached. In the next hour the culture was induced for product formation with 1M IPTG. In case of Q culture quiescence was induced with 0.5M Indole just 5min after induction with IPTG. Post induction every hour samples were collected and frozen with liquid nitrogen and stored at -80ºC for further analytical use. Total RNA extraction, RNA quality control (Agilent BioAnalyser), total RNA labeling, microarray hybridization and scanning were performed according to the Affymetrix GeneChip Expression analysis .

Project description:In Escherichia coli, many recombinant proteins are produced in the periplasm. To direct these proteins to this compartment, they are equipped with an N-terminal signal sequence so that they can traverse the cytoplasmic membrane via the protein-conducting Sec translocon. Recently, using the single-chain variable antibody fragment BL1, we have shown that harmonizing the target gene expression intensity with the Sec translocon capacity can be used to improve the production yields of a recombinant protein in the periplasm. Here, we have studied the consequences of improving the production of BL1 in the periplasm by using a proteomics approach. When the target gene expression intensity is not harmonized with the Sec translocon capacity, the impaired translocation of secretory proteins, protein misfolding/aggregation in the cytoplasm, and an inefficient energy metabolism result in poor growth and low protein production yields. The harmonization of the target gene expression intensity with the Sec translocon capacity results in normal growth, enhanced protein production yields, and, surprisingly, a composition of the proteome that is-besides the produced target-the same as that of cells with an empty expression vector. Thus, the single-chain variable antibody fragment BL1 can be efficiently produced in the periplasm without causing any notable detrimental effects to the production host. Finally, we show that under the optimized conditions, a small fraction of the target protein is released into the extracellular milieu via outer membrane vesicles. We envisage that our observations can be used to design strategies to further improve the production of secretory recombinant proteins in E. coliIMPORTANCE The bacterium Escherichia coli is widely used to produce recombinant proteins. Usually, trial-and-error-based screening approaches are used to identify conditions that lead to high recombinant protein production yields. Here, for the production of an antibody fragment in the periplasm of E. coli, we show that an optimization of its production is accompanied by the alleviation of stress. This indicates that the monitoring of stress responses could be used to facilitate enhanced recombinant protein production yields.

Dataset Information

Acetate formation during recombinant protein production in Escherichia coli K-12 with an elevated NAD(H) pool.

Publications

Acetate formation during recombinant protein production in <i>Escherichia coli</i> K-12 with an elevated NAD(H) pool.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure

Tweets