Conversion of Mixtures of Soybean Curd Residue and Kitchen Waste by Black Soldier Fly Larvae (Hermetia illucens L.).
Ontology highlight
ABSTRACT:
SUBMITTER: Li X
PROVIDER: S-EPMC8779397 | biostudies-literature |
REPOSITORIES: biostudies-literature
Similar Datasets
Project description:Black soldier fly (BSF, Hermetia illucens) larvae are considered as insects with a high potential to convert organic waste into high-value products. The objective of this study was to investigate the growth performance, waste reduction efficiency, and nutritional composition of BSF reared on different ratios of coconut endosperm (C) and soybean curd residue (S), with or without supplementation, compared to standard diets (Gainesville: G and starter chicken diet: CK). Seven-day-old larvae were randomly divided into eight experimental groups (G, CK, and three different ratios of C and S with or without supplementation) with three replicates with an equal weight of larvae. The supplement contained calcium, phosphorus, amino acids, and a mineral-vitamin premix which was formulated to correlate with CK. Each replicate was terminated, measured, and evaluated when 40% of larvae had reached prepupal stage. The highest larval weight gain was presented in BSF fed CK, followed by those fed coconut endosperm and soybean curd residue at a ratio of 20:80 (C20S80), and coconut endosperm and soybean curd residue at a ratio of 50:50 (C50S50) without supplementation (numbers after C and S represent their percentage in the formulation; p < 0.001). Harvesting was delayed in the BSF fed C80S20 with and without supplementation (p < 0.001). The number of total larvae and prepupae was not significantly different between groups (p > 0.05). The greatest waste reduction efficiency was observed in the G, C50S50, and C20S80 groups without supplementation (p < 0.001). All groups with supplementation had a higher proportion of ash in both larvae and prepupae compared to non-supplemented groups (p < 0.001), but lower growth performance. The highest percentage of crude protein in larvae was presented in the Gainesville and C20S80 groups followed by the CK and C50S50 groups (p < 0.001). Equal proportions of C and S without supplementation are suggested as a rearing substrate. However, growth performance was lower than for CK; therefore, further studies could investigate cost-efficient techniques to promote this parameter.
| S-EPMC8396427 | biostudies-literature
Project description:Vermicomposting using black soldier fly (BSF) larvae (Hermetia illucens) has gradually become a promising biotechnology for waste management, but knowledge about the larvae gut microbiome is sparse. In this study, 16S rRNA sequencing, SourceTracker, and network analysis were leveraged to decipher the influence of larvae gut microbiome on food waste (FW) biodegradation. The microbial community structure of BSF vermicompost (BC) changed greatly after larvae inoculation, with a peak colonization traceable to gut bacteria of 66.0%. The relative abundance of 11 out of 21 metabolic function groups in BC were significantly higher than that in natural composting (NC), such as carbohydrate-active enzymes. In addition, 36.5% of the functional genes in BC were significantly higher than those in NC. The changes of metabolic functions and functional genes were significantly correlated with the microbial succession. Moreover, the bacteria that proliferated in vermicompost, including Corynebacterium, Vagococcus, and Providencia, had strong metabolic abilities. Systematic and complex interactions between the BSF gut and BC bacteria occurred over time through invasion, altered the microbial community structure, and thus evolved into a new intermediate niche favourable for FW biodegradation. The study highlights BSF gut microbiome as an engine for FW bioconversion, which is conducive to bioproducts regeneration from wastes.
| S-EPMC6465238 | biostudies-literature
Project description:Insects are a promising alternative protein source. One of the bottlenecks in applying insects in food is the fast darkening initiated during grinding. Besides enzymatic browning, non-enzymatic factors can cause off-colour formation, which differs between species. This study investigates the impact of iron, phenoloxidase, and polyphenols on off-colour formation in insect larvae. Hermetia illucens showed a blackish colour, whereas Tenebrio molitor turned brown and Alphitobius diaperinus remained the lightest. This off-colour formation appeared correlated with the iron content in the larvae, which was 61?±?9.71, 54?±?1.72 and 221?±?6.07?mg/kg dw for T. molitor, A. diaperinus and H. illucens, respectively. In model systems, the formation of iron-L-3,4-dihydroxyphenylalanine (L-DOPA) bis- and tris-complexes were evidenced by direct injection into ESI-TOF-MS, based on their charges combined with iron isotope patterns. The reversibility of the binding of iron to phenolics, and thereby loss of blackening, was confirmed by EDTA addition. Besides complex formation, oxidation of L-DOPA by redox reactions with iron occurred mainly at low pH, whereas auto-oxidation of L-DOPA mainly occurred at pH 10. Tyrosinase (i.e. phenoloxidase) activity did not change complex formation. The similarity in off-colour formation between the model system and insects indicated an important role for iron-phenolic complexation in blackening.
| S-EPMC6393531 | biostudies-literature
Project description:The black soldier fly is currently the most produced edible insect on industrial scale, with its larval stage being processed into animal feed as the main application. As this insect species enters the feed and food chain, good hygiene and monitoring practices are needed to avoid the entrance of foodborne pathogens via the larvae. However, insufficient data on the risk of such introductions via industrial larvae production are available. To address this gap, a range of rearing trials were conducted in which the substrate, chicken feed, was inoculated with different levels of Salmonella and in which total viable counts and Salmonella counts were determined during the following days. The outgrowth of Salmonella was slower in those experiments with a lower initial contamination level than in experiments with a higher level. No significant reducing effect originating from the larvae on the substrate Salmonella counts was observed, in contrast to previous studies using other substrates. Our study also revealed that airborne transmission of Salmonella is possible under rearing conditions corresponding to those applied at industrial production sites. Based on our results, we recommend insect producers to use substrate ingredients free of Salmonella, and not to count on the antimicrobial activities that BSFL may exert in some situations towards food pathogens. More inoculation studies using other Salmonella serotypes, other zoonotic bacteria, other substrates, larvae of other ages and including variations on rearing protocols are needed in order to obtain a general view on the dynamics of food pathogens in this insect species and to support comprehensive risk assessments.
| S-EPMC8505792 | biostudies-literature
Project description:Nutritional value of black soldier fly (Hermetia illucens) larvae (BSFL) processed by three different methods of treatment was compared. The resulting products were the spray-dried BSFL (SPR), oven-dried BSFL 1 (OVN1) and oven-dried BSFL 2 (OVN2). Proximate chemical composition, and profiles of amino acids, fatty acids, minerals, heavy metals, vitamins and nucleotides were analysed and compared. The tested BSFL meals were considered to have a good profile of essential amino acids (EAAs), with leucine, lysine, valine, and histidine being the dominant EAAs. Their content of saturated fatty acids exceeded that of the unsaturated fatty acids. Vitamins B1, B2, and C were also present in the samples. Minerals such as calcium, potassium, phosphorus, sodium, magnesium, zinc, iron, manganese and copper were found to be in adequate amounts in almost all the samples. Heavy metals in the BSFL meals were mostly below 1g kg-1. Nucleotides such as inosine monophosphate and uridine monophosphate occurred in all the BSFL meals. Other nucleotides, including guanosine monophosphate, adenosine monophosphate, xanthosine monophosphate, and cytidine monophosphate were detected in either or both of SPR and OVN2. In general, the nutritional value of the BSFL meals tested in the present study was influenced by the method of processing.
| S-EPMC8880436 | biostudies-literature
Project description:Black soldier fly (BSF) larvae have been marketed as an excellent choice for providing calcium to reptiles without the need of dusting or gut loading. However, previous studies have indicated that they have limited calcium digestibility and are deficient in fat soluble vitamins (A, D3, and E). In this feeding and digestibility trial, 24 adult male leopard geckos were fed one of three diets for 4 months: 1) whole, vitamin A gut loaded larvae; 2) needle pierced, vitamin A gut loaded larvae; or 3) whole, non-gut loaded larvae. Fecal output from the geckos was collected daily and apparent digestibility was calculated for dry matter, protein, fat, and minerals. There were no differences in digestibility coefficients among groups. Most nutrients were well digested by the leopard geckos when compared to previous studies, with the exception of calcium (digestibility co-efficient 43%), as the calcium-rich exoskeleton usually remained intact after passage through the GI tract. Biochemistry profiles revealed possible deficits occurring over time for calcium, sodium, and total protein. In regards to vitamin A digestibility, plasma and liver vitamin A concentrations were significantly higher in the supplemented groups (plasma- gut loaded groups: 33.38 ± 7.11 ng/ml, control group: 25.8 ± 6.72 ng/ml, t = 1.906, p = 0.04; liver- gut loaded groups: 28.67 ± 18.90 ?g/g, control group: 14.13 ± 7.41 ?g/g, t = 1.951, p = 0.03). While leopard geckos are able to digest most of the nutrients provided by BSF larvae, including those that have been gut loaded, more research needs to be performed to assess whether or not they provide adequate calcium in their non-supplemented form.
| S-EPMC7213736 | biostudies-literature
Project description:Black soldier fly (BSF) larvae, Hermetia illucens (Diptera: Stratiomyidae) have emerged as an efficient system for the bioconversion of organic waste. Intestinal microorganisms are involved in several insect functions, including the development, nutrition, and physiology of the host. In order to transform the intestinal bacterial community of BSF directionally, six different potential functional strains (Lysinibacillus sphaericus, Proteus mirabilis, Citrobacter freundii, Pseudocitrobacter faecalis, Pseudocitrobacter anthropi, and Enterococcus faecalis) were added to aseptic food waste, and aseptic food waste was used without inoculants as a blank control to evaluate the changes in the intestinal microbiota of BSF under artificial intervention conditions. These six strains (which were isolated from the larval intestinal tract in selective media and then identified and screened) may be considered responsible for the functional characteristics of larvae. The results imply that the increase in the abundance of Lysinibacillus in the experimental group that was exposed to Lysinibacillus sphaericus was significantly different to the other groups (p < 0.05). The results revealed that it is feasible to transform the intestinal microbiota of BSF directionally; there are differences in the proliferation of different strains in the intestine of BSF.
| S-EPMC8697953 | biostudies-literature
Project description:Supermarket food waste, constituting 13% of global food waste, can be upcycled as substrate for black soldier fly larvae (BSFL) and converted into larval biomass. Since presence of food pathogens in supermarket food waste is likely, microbiological safety should be ensured when using waste as insect substrate. Heat treatment provides a suitable pre-treatment to reduce microbiological contaminations. This study investigated the effect of different temperature-time combinations on the microbiological safety of supermarket food waste as BSFL substrate. Artificial supermarket food waste without meat and fish (SFW) was inoculated with both Salmonella and Staphylococcus aureus (7.0log cfu/g) and treated at 50 and 60 °C for 10, 20 and 30 min. While 50 °C was insufficient for adequate pathogen reduction, 60 °C only required 10 min to reduce the Enterobacteriaceae and S.aureus counts to < 1.0logcfu/g and for absence of Salmonella in 25 g. Heat-treated SFW could be stored for two days at ambient temperature or refrigerated without pathogen growth. Treatment of supermarket food waste containing meat and fish at 60 °C for 10 min caused similar results as for SFW, but S.aureus persisted (2.4logcfu/g), possibly by protective effects of fat and/or proteins. Finally, BSFL rearing experiments on SFW revealed significantly higher larval mass, bioconversion efficiency and waste reduction than on Gainesville diet, with no notable differences between untreated and heat-treated SFW. Rearing BSFL on supermarket food waste is possible, and unsafe food waste can be heated to obtain safety without eliminating nutrients necessary for rearing.
| S-EPMC10162384 | biostudies-literature
Project description:Residues of persistent insecticides may be present in the substrates on which insects are reared for food and feed, which may affect insect growth or survival. In addition, insecticidal substances may bio-accumulate in reared insects. The objective of this study was to assess potential effects of selected insecticides on the growth and survival of black soldier fly larvae (BSFL, Hermetia illucens) and on their safety when used as animal feed. Six insecticides (chlorpyrifos, propoxur, cypermethrin, imidacloprid, spinosad, tebufenozide) with different modes of action were tested in two sequential experiments. Cypermethrin was also tested with the synergist piperonyl butoxide (PBO). Standard BSFL substrate was spiked to the respective maximum residue level (MRL) of each insecticide allowed by the European Union to occur in feed; and BSFL were reared on these substrates. Depending on the observed effects in the first experiment, spiked concentrations tested in the second experiment were increased or reduced. At the concentrations applied (1 and 10 times MRL), three of the six tested substances (chlorpyrifos, propoxur, tebufenozide) did not affect the survival or biomass growth of BSFL, compared to the control (non-spiked) treatments. At MRL, imidacloprid stimulated the growth of BSFL compared to the controls. Spinosad and cypermethrin at the MRL level negatively affected growth and survival. The effects of cypermethrin appeared to be augmented by addition of PBO. A mean bio-accumulation factor of ≤0.01 was found in both experiments for all substances-except for cypermethrin, which was comparatively high, but still below 1 (0.79 at 0.1 mg/kg). The lack of accumulation of insecticides in the larvae suggests that there is no risk of larval products being uncompliant with feed MRLs. However, we conclude that insecticides present in substrates may affect growth and survival of BSFL. More research on a larger variety of substances and insect species is recommended.
| S-EPMC8059818 | biostudies-literature
Project description:The black soldier fly (BSF), Hermetia illucens (L., 1758) (Diptera: Stratiomyidae), is an endemic fly species from the tropical, subtropical and warm temperate zones of America. This saprophagous species relies on its environment where it finds the decomposing matter for the larvae to grow. The polyphagous diet and the macronutrient quality (mainly lipids and proteins) of these larvae make them excellent candidates for various applications such as waste and organic material management, incorporation in animal feed or alternative energy source. Although rearing development in temperate regions requires artificial processes to continuously produce high quality eggs and larvae, few studies have been conducted on the mating and oviposition processes governing H. illucens reproduction. Research conducted in semi-artificial rearing conditions showed that the number of mating varied according to the season. It has been speculated that this behavior could be due to differences in the intensity of sunlight caused by the change of seasons. This study aims at evaluating the influence of sex-ratio, density and nycthemeral cycle on H. illucens reproduction. In order to tackle this issue, an artificial set up for oviposition to collect eggs has been developed. This egg collection system aims at centralize oviposition and simplify eggs collection. Two populations with opposite sex-ratio (male-dominant and female-dominant) were selected. Their respective eggs productions have been evaluated for five breeding densities. Eggs weights varied significantly among the densities for each opposite sex-ratio population and female dominant population produced most eggs weight from 6500 individuals /m3. Finally, four nycthemeral cycles (2, 6, 12 and 18h of daily light) were simulated to evaluate the impact of light duration on reproduction. Early oviposition pic associated with a decrease of the oviposition period are shown when H. illucens are exposed to increasing light duration. These experiments enable improvement of the understanding on artificial reproduction of H. illucens.
| S-EPMC6490921 | biostudies-literature