Dataset Information

Co-Pyrolysis of Sewage Sludge and Wetland Biomass Waste for Biochar Production: Behaviors of Phosphorus and Heavy Metals.

ABSTRACT: Large amounts of sewage sludge (SS) and wetland plant wastes are generated in the wastewater treatment system worldwide. The conversion of these solid wastes into biochar through co-pyrolysis could be a promising resource utilization scheme. In this study, biochar was prepared by co-pyrolysis of SS and reed (Phragmites australis, RD) using a modified muffle furnace device under different temperatures (300, 500, and 700 °C) and with different mixing ratios (25, 50, and 75 wt.% RD). The physicochemical properties of biochar and the transformation behaviors of phosphorus (P) and heavy metals during the co-pyrolysis process were studied. Compared with single SS pyrolysis, the biochar derived from SS-RD co-pyrolysis had lower yield and ash content, higher pH, C content, and aromatic structure. The addition of RD could reduce the total P content of biochar and promote the transformation from non-apatite inorganic phosphorus (NAIP) to apatite phosphorus (AP). In addition, co-pyrolysis also reduced the content and toxicity of heavy metals in biochar. Therefore, co-pyrolysis could be a promising strategy to achieve the simultaneous treatment of SS and RD, as well as the production of value-added biochar.

SUBMITTER: Gbouri I

PROVIDER: S-EPMC8909961 | biostudies-literature | 2022 Feb

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Co-Pyrolysis of Sewage Sludge and Wetland Biomass Waste for Biochar Production: Behaviors of Phosphorus and Heavy Metals.

Gbouri Ilham I Yu Fan F Wang Xutong X Wang Junxia J Cui Xiaoqiang X Hu Yanjun Y Yan Beibei B Chen Guanyi G

International journal of environmental research and public health 20220228 5

Large amounts of sewage sludge (SS) and wetland plant wastes are generated in the wastewater treatment system worldwide. The conversion of these solid wastes into biochar through co-pyrolysis could be a promising resource utilization scheme. In this study, biochar was prepared by co-pyrolysis of SS and reed (<i>Phragmites australis</i>, RD) using a modified muffle furnace device under different temperatures (300, 500, and 700 °C) and with different mixing ratios (25, 50, and 75 wt.% RD). The phy ...[more]

PMID: 35270520

Similar Datasets

Project description:Agricultural application of sewage sludge (SS) after carbonization is a plausible way for disposal. Despite its benefits of improving soil fertility and C sequestration, heavy metals contained in sewage sludge biochars (SSB) are still a concern. In this study, two types of heavy metal stabilizers were chosen: fulvic acid (FA) and phosphogypsum (with CaSO4, CS, as the main component). The two stabilizers were incorporated into SS prior to 350°C carbonization for 1 h at the rates of 1%, 2%, or 4%. The obtained SSBs were then analyzed by Fourier transform infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS). Total and available concentrations of four heavy metals, i.e., Zn, Pb, Cd, and Ni, in the SSBs were determined. In addition, a series of pot soil culture experiments was conducted to investigate the effects of stabilizers incorporation into SSB on heavy metal bioavailability and the uptake by plants (corn as an indicator) and plant biomass yield, with SS and SSB (no stabilizers) as controls. The results showed that incorporation of both FA and CS increased functional groups such as carboxyl, phenol, hydroxyl, amine and quinine groups in the SSBs. The percentage of heavy metals in sulfuric and oxidizable state and residual state of SSBs were significantly increased after carbonization, and hence the mobility of the heavy metals in SSBs was decreased. The introduction of the stabilizers (i.e., FA or CS) significantly lowered the total and available concentrations of Zn, Pb, Cd, and Ni. The reduction in available heavy metal concentration increased with incorporation rate of the stabilizers from 1% to 4%. In the treatments with FA or CS incorporated SSB, less heavy metals were taken up by plants and more plant biomass yields were obtained. The mitigating effects were more pronounced at higher rates of FA or CS stabilizer. These findings provide a way to lower bioavailability of heavy metals in SS or SSB for land application or horticulture as a peat substitute.

Project description:Improved technologies are needed for sustainable management of sewage sludge (SS). The torrefaction (also known as biomass "roasting") is considered a pretreatment of SS before use in agriculture. However, it is not known whether the torrefaction has the potential to decrease heavy metals' (HMs) leachability and the SS toxicity. Thus, the aim of the study was to evaluate the influences of the SS torrefaction parameters (temperature and process time) on HM contents in biochar, HM leachability, and biochar toxicity, and compare them with raw SS. The experiments were designed in 18 combinations (six temperatures, 200, 220, 240, 260, 280, and 300 °C; and three process times-20, 40, 60 min). Standard tests were used to determine HMs content, leachability, and toxicity. Results indicated that the torrefaction did not increase (p < 0.05) the HM content in comparison to the raw SS. The leachability of Zn, Ni, Cu, Cr, and Mn from SS biochars was similar to raw SS. However, the degree of leachability varied significantly (p < 0.05) from as low as 0.1% for Cu to high as 16.7% for Cd. The leachability of Cd (<16.7%) and Pb (<11.9%) from biochars was higher than from raw SS (<6.1% and <2.4%, respectively). The leachability of Cd from SS biochar, in five torrefaction combinations, was higher than the threshold value for hazardous waste. It is recommended that site-specific decisions are made for torrefaction of SS with respect to its HM content, as the resulting biochar could be considered as hazardous waste, depending on the feedstock. Moreover, the biochar produced under the whole range of temperatures during 20 min retention time significantly (p < 0.05) increased the Daphnia magna Straus mobility inhibition by up to 100% in comparison to the biochar obtained during 40 and 60 min torrefaction. Taking into account the increased leachability of specific HMs and D. magna Straus mobility inhibition, biochar should be considered a potentially hazardous material. Future research should focus on biochar dosage as a fertilizer in relation to its toxicity. Additional research is warranted to focus on the optimization of SS torrefaction process parameters affecting the toxicity.

Project description:Sewage sludge and livestock (chicken, swine and cattle) manure samples were collected from the Yanmenguan Cattle Herbivorous Livestock Area to compare the potential ecological and human health risks caused by heavy metals contained in them. In this study, the Class II level of Quality Control of Imported Organic Fertilizers is selected as the limit standard value of heavy metals. Based on the mean content values, no heavy metal in cattle manure was higher than the limit standard value; the content of Cu in swine manure was higher than the limit of Cu; the content of Zn in sewage sludge, chicken manure and swine manure were all higher than the limit of Zn; and the content of Cr in sewage sludge and chicken manure were all higher than the limit of Cr. Results indicated that sewage sludge and livestock manure all had high contents of Zn, Cu and Cr. The mean pollution index (PI) suggested that Cu, Zn, As and Cr in sewage sludge and livestock manures all induced potential ecological risks. According to the mean Nemerow's synthetic pollution index (PN) values, swine manure had the highest potential ecological risk for agricultural use. Daily exposure to Cu, Zn and Cr was higher than other heavy metals from sewage sludge and livestock manures, and heavy metal exposure was always higher for children than adults, with ingestion as the main pathway. Non-carcinogenic risk was caused mainly by Cu and Cr, based on the higher hazard quotient (HQ) values for adults and children. There was no non-carcinogenic risk for all people, except exposure of Cu from swine manure for children, which was 1.76 times higher than the threshold value of 1. According to the mean hazard index (HI) values, only swine manure had a non-carcinogenic risk for children. As the carcinogenic risk index (Risk) values were continuously greater for As than Cd, As had a higher carcinogenic risk than Cd. There was no carcinogenic risk for any single heavy metal, although As exposure from sewage sludge was found to have an inapparent carcinogenic risk for both adults and children. Regarding the RISK value, sewage sludge had an unacceptable carcinogenic risk for adults and children, and swine manure had an unacceptable risk for children only. In general, for both non-carcinogenic and carcinogenic risks, ingestion was the main pathway, and children were more sensitive than adults. Comparing the four kinds of organic waste, cattle manure was the safest for agricultural use in terms of ecological and human health risks. In multiple comparisons, swine manure was significantly different regarding potential ecological risk and non-carcinogenic risk, and sewage sludge was significantly different regarding carcinogenic risk.

Dataset Information

Co-Pyrolysis of Sewage Sludge and Wetland Biomass Waste for Biochar Production: Behaviors of Phosphorus and Heavy Metals.

Publications

Co-Pyrolysis of Sewage Sludge and Wetland Biomass Waste for Biochar Production: Behaviors of Phosphorus and Heavy Metals.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure

Tweets