Dataset Information

Efficacy of using an intravenous catheter to repair damaged expansion lines of endotracheal tubes and laryngeal masks.

ABSTRACT:

Background

In perioperative care or intensive care units, the expansion lines of endotracheal tubes (ETTs) or laryngeal mask airways (LMAs) may be accidentally cut off during medical procedures. We designed a simple method for repairing damaged ETT and LMA expansion lines.

Methods

In this in vitro study, ETT (n = 20) or LMA (n = 20) models were each categorized into experimental (n = 10) and control (n = 10) groups. In the experimental groups, the expansion lines were cut in the middle, and a 22G intravenous catheter was inserted into the broken end of each expansion line. The time taken to repair the expansion lines was recorded in both experimental groups. The repaired expansion lines in both groups were tested for visible underwater air leakage with cuffs under high pressure (120 cm H2O). After 15 h, the cuff pressure and tensile strength of the expansion lines were measured.

Results

The overall time required to repair the expansion line was 27.8 ± 1.5 s in the ETT group and 20.4 ± 1.1 s in the LMA group. When the cuff pressure was increased to 120 cmH₂O, no air leakage was observed in the experimental LMA and ETT groups. The mean difference in the cuff pressures of the control and experimental groups was insignificant for both, ETT (9.50 ± 1.29 vs. 9.50 ± 1.08 cmH₂O, 95% CI = - 1.11 to 1.11 cmH₂O, P = 1.00) and LMA (34.1 ± 1.10 cmH₂O vs. 34.5 ± 0.97 cmH₂O, 95% CI = - 0.57 to 1.37 cmH₂O, P = 0.40) groups, The tensile strength and the force required to pull apart the expansion lines in the experimental groups were lower than those in the control groups for ETTs (3.32 ± 0.37 N vs. 35.03 ± 4.47 N, 95% CI = - 34.69 to - 28.72 N, P < 0.0001) and LMAs (36.55 ± 2.20 N vs. 26.18 ± 1.67 N, 95% CI = - 12.21 to - 8.53 N, P < 0.0001).

Conclusion

An intravenous catheter can be directly inserted into the damaged ETT or LMA expansion lines; it is a simple, rapid, and effective repair method.

SUBMITTER: Wang T

PROVIDER: S-EPMC9316419 | biostudies-literature |

REPOSITORIES: biostudies-literature

ACCESS DATA

Similar Datasets

Project description:ObjectiveFlexible laryngeal mask airways (FLMAs) have been widely used in thyroidectomy as well as cleft palate, nasal, upper chest, head and neck oncoplastic surgeries. This systematic review aims to compare the incidence of airway complications that occur during and after general anesthesia when using the FLMA and endotracheal intubation (ETT). We performed a quantitative meta-analysis of the results of randomized trials.MethodsA comprehensive search of the PubMed, Embase and Cochrane Library databases was conducted using the key words "flexible laryngeal mask airway" and "endotracheal intubation". Only prospective randomized controlled trials (RCTs) that compared the FLMA and ETT were included. The relative risks (RRs) and the corresponding 95% confidence intervals (95% CIs) were calculated using a quality effects model in MetaXL 1.3 software to analyze the outcome data.ResultsTen RCTs were included in this meta-analysis. There were no significant differences between the FLMA and ETT groups in the incidence of difficulty in positioning the airway [RR = 1.75, 95% CI = (0.70-4.40)]; the occurrence of sore throat at one hour and 24 hours postoperative [RR = 0.90, 95% CI = (0.13-6.18) and RR = 0.95, 95% CI = (0.81-1.13), respectively]; laryngospasms [RR = 0.58, 95% CI = (0.27-1.23)]; airway displacement [RR = 2.88, 95% CI = (0.58-14.33)]; aspiration [RR = 0.76, 95% CI = (0.06-8.88)]; or laryngotracheal soiling [RR = 0.34, 95% CI = (0.10-1.06)]. Patients treated with the FLMA had a lower incidence of hoarseness [RR = 0.31, 95% CI = (0.15-0.62)]; coughing [RR = 0.28, 95% CI = (0.15-0.51)] during recovery in the postanesthesia care unit (PACU); and oxygen desaturation [RR = 0.43, 95% CI = (0.26-0.72)] than did patients treated with ETT. However, the incidence of partial upper airway obstruction in FLMA patients was significantly greater than it was for ETT patients [RR = 4.01, 95% CI = (1.44-11.18)].ConclusionThis systematic review showed that the FLMA has some advantages over ETT because it results in a lower incidence of hoarseness, coughing and oxygen desaturation. There were no statistically significant differences in the difficulty of intubation or in the occurrence of laryngospasms, postoperative sore throat, airway displacement, aspiration or laryngotracheal soiling. However, there was a higher incidence of partial upper airway obstruction in the FLMA than in the ETT group. We conclude that the FLMA has some advantages over ETT, but surgeons and anesthesiologists should be cautious when applying the mouth gag, moving the head and neck, or performing oropharyngeal procedures to avoid partial upper airway obstruction and airway displacement. The FLMA should not be used on patients at high risk for aspiration.

Project description:BackgroundBiofilm on the surface of endotracheal tubes (ETTs) is associated with ventilator-associated pneumonia. The use of silver-coated ETTs has been suggested to reduce the occurrence of ventilator-associated pneumonia by preventing biofilm formation. However, mucus accumulation can reduce the antibacterial activity of silver-coated ETTs by isolating bacterial colonies from the silver surface. We hypothesized that, in mechanically ventilated subjects, periodic removal of secretions through the use of a cleaning device would enhance the antimicrobial properties of silver-coated ETTs and thus reduce bacterial colonization.MethodsSubjects were randomized to either standard suctioning (blind tracheal suctioning, control group) or blind tracheal suctioning plus cleaning maneuver every 8 h (treatment group). Tracheal aspirates were collected immediately before extubation for microbiological culture. After extubation, ETTs were collected for both cultural and non-cultural microbiological analysis and biofilm isolation.Results39 subjects expected to be ventilated for > 48 h were enrolled; 36 ETTs (18 control, 18 treatment) and 29 tracheal samples (15 control, 14 treatment) were collected. Among the ETTs positive for bacterial colonization (15 vs 9, P = .18), cleaning maneuvers did not reduce microbial load, shown as the decimal logarithm of colony-forming units (CFU) per mL (1.6 ± 1.2 vs 0.9 ± 1.2 logCFU/mL, P = .15). There was a trend toward decreased biofilm deposition (439.5 ± 29.0 vs 288.9 ± 157.7 mg, P = .09) in the treated ETTs. No significant differences were observed in the number of positive tracheal aspirates (13 vs 10, P = .39) or in the microbial load (4.8 ± 4.0 vs 4.2 ± 3.8 logCFU/mL, P = .70) of tracheal secretions. Finally, no differences in the microbial load of Gram-positive organisms, Gram-negative organisms, or yeasts were found between the ETTs and tracheal aspirates of the 2 groups.ConclusionsIn 39 critically-ill subjects intubated with silver-coated ETTs, periodic cleaning maneuvers did not decrease bacterial colonization of the ETTs and did not lower respiratory tract colonization compared to the standard suctioning. (Clinicaltrials.gov registration NCT02120001.).

Project description:BackgroundBiofilm formation on endotracheal tubes (ETTs) is an early and frequent event in mechanically ventilated patients. The biofilm is believed to act as a reservoir for infecting microorganisms and thereby contribute to development and relapses of ventilator-associated pneumonia (VAP). Once a biofilm has formed on an ETT surface, it is difficult to eradicate. This clinical study aimed to compare biofilm formation on three widely used ETTs with different surface properties and to explore factors potentially predictive of biofilm formation.MethodsWe compared the grade of biofilm formation on ETTs made of uncoated polyvinyl chloride (PVC), silicone-coated PVC, and PVC coated with noble metals after > 24 h of mechanical ventilation in critically ill patients. The comparison was based on scanning electron microscopy of ETT surfaces, biofilm grading, surveillance and biofilm cultures, and occurrence of VAP.ResultsHigh-grade (score ≥ 7) biofilm formation on the ETTs was associated with development of VAP (OR 4.17 [95% CI 1.14-15.3], p = 0.031). Compared to uncoated PVC ETTs, the silicone-coated and noble-metal-coated PVC ETTs were independently associated with reduced high-grade biofilm formation (OR 0.18 [95% CI 0.06-0.59], p = 0.005, and OR 0.34 [95% CI 0.13-0.93], p = 0.036, respectively). No significant difference was observed between silicon-coated ETTs and noble-metal-coated ETTs (OR 0.54 [95% CI 0.17-1.65], p = 0.278). In 60% of the oropharyngeal cultures and 58% of the endotracheal cultures collected at intubation, the same microorganism was found in the ETT biofilm at extubation. In patients who developed VAP, the causative microbe remained in the biofilm in 56% of cases, despite appropriate antibiotic therapy. High-grade biofilm formation on ETTs was not predicted by either colonization with common VAP pathogens in surveillance cultures or duration of invasive ventilation.ConclusionHigh-grade biofilm formation on ETTs was associated with development of VAP. Compared to the uncoated PVC ETTs, the silicone-coated and noble-metal-coated PVC ETTs were independently associated with reduced high-grade biofilm formation. Further research on methods to prevent, monitor, and manage biofilm occurrence is needed.Trial registrationClinicalTrials.gov NCT02284438 . Retrospectively registered on 21 October 2014.

Project description:Ventilator-associated pneumonia (VAP) is a prevalent and costly nosocomial infection related to instrumentation of the airway with an endotracheal tube (ETT), enabling microaspiration of contaminated secretions. Modification of the ETT design to reduce microaspiration and/or biofilm formation may play an important role in VAP prevention. However, there is insufficient evidence to provide strong recommendations regarding the use of modified ETT and unaddressed safety concerns.We performed a pilot randomized controlled trial comparing two modified ETTs designed specifically to prevent VAP, with the standard ETT, to test the feasibility of and inform planning for a large, pivotal, randomized trial.This study was conducted with institutional review board approval under exception from informed consent. We randomized in a blinded fashion patients undergoing emergency endotracheal intubation both out of and in hospital to receive one of three different ETT types: (1) a polyurethane-cuffed tube (PUC-ETT), (2) a polyurethane-cuffed tube equipped with a port for continuous aspiration of subglottic secretions (PUC-CASS-ETT), or a (3) standard polyvinylchloride-cuffed tube (PVC-ETT). In addition to investigating feasibility and safety, the study coprimary end points were tracheal bacterial colonization reaching a cfu count >10(6) cfu per milliliter and the incidence of invasively diagnosed VAP.A total of 102 subjects were randomized and met the eligibility criteria. Randomization procedures performed well and integrity of blinding at randomization was maintained. The majority of intubations occurred in the hospital setting (n?=?77), and the remainder occurred out of hospital (n?=?25). Compared with the PVC-ETT, there were no significant differences in tracheal colonization for PUC-ETT (odds ratio [OR], 0.98; 95% confidence interval [CI], 0.31-3.09) or for PUC-CASS-ETT (OR, 1.26; 95% CI, 0.42-3.76). There were no differences in the risk of invasively diagnosed VAP (OR, 1.14; 95% CI, 0.21-6.08 for PUC-ETT; OR, 1.47; 95% CI, 0.30-7.10 for PUC-CASS-ETT), or of clinically diagnosed VAP by either clinical signs or chest radiograph criteria. We did not observe unexpected or serious adverse events related to the devices.A randomized trial of ETTs inserted during emergency intubation for the prevention of VAP is feasible and did not appear to carry heightened safety concerns. These preliminary data did not suggest different patterns of tracheal colonization or occurrence of VAP among the study groups. Clinical trial registered with www.clinicaltrials.gov (NCT01744483).