Dataset Information

Synergy of the flow behaviour and disperse phase of cellulose nanoparticles in enhancing oil recovery at reservoir condition.

ABSTRACT: Ascorbic acid was used for the first time to synthesize cellulose nanoparticles (CNP) extracted from okra mucilage. The physical properties of the CNP including their size distribution, and crystalline structures were investigated. The rheological properties of the cellulose nanofluid (CNF) were compared with the bulk okra mucilage and commercial polymer xanthan. The interfacial properties of the CNF at the interface of oil-water (O/W) system were investigated at different concentrations and temperatures. The effects of the interaction between the electrolyte and ultrasonic were determined. Core flooding experiment was conducted at reservoir condition to justify the effect of the flow behaviour and disperse phase behaviour of CNF on additional oil recovery. The performance of the CNF was compared to conventional EOR chemical. The combined method of ultrasonic, weak-acid hydrolysis and nanoprecipitation were effective in producing spherical and polygonal nanoparticles with a mean diameter of 100 nm, increased yield of 51% and preserved crystallinity respectively. The zeta potential result shows that the CNF was stable, and the surface charge signifies long term stability of the fluid when injected into oil field reservoirs. The CNF, okra and xanthan exhibited shear-thinning and pseudoplastic behaviour. The IFT decreased with increase in concentration of CNF, electrolyte and temperature. The pressure drop data confirmed the stability of CNF at 120°C and the formation of oil bank was enough to increase the oil recovery by 20%. CNF was found to be very effective in mobilizing residual oil at high-temperature high-pressure (HTHP) reservoir condition. The energy and cost estimations have shown that investing in ultrasonic-assisted weak-acid hydrolysis is easier, cost-effective, and can reduce energy consumption making the method economically advantageous compared to conventional methods.

SUBMITTER: Agi A

PROVIDER: S-EPMC6764795 | biostudies-literature | 2019

REPOSITORIES: biostudies-literature

ACCESS DATA

Publications

Synergy of the flow behaviour and disperse phase of cellulose nanoparticles in enhancing oil recovery at reservoir condition.

Agi Augustine A Junin Radzuan R Arsad Agus A Abbas Azza A Gbadamosi Afeez A Azli Nur Bashirah NB Oseh Jeffrey J

PloS one 20190927 9

Ascorbic acid was used for the first time to synthesize cellulose nanoparticles (CNP) extracted from okra mucilage. The physical properties of the CNP including their size distribution, and crystalline structures were investigated. The rheological properties of the cellulose nanofluid (CNF) were compared with the bulk okra mucilage and commercial polymer xanthan. The interfacial properties of the CNF at the interface of oil-water (O/W) system were investigated at different concentrations and tem ...[more]

PMID: 31560699

Similar Datasets

Project description:In this work, a newly engineered alumina quantum dot-based nanofluid (α-AQDs; D ~ 4 nm; amorphous solid) and one commercial alumina nanoparticle-based nanofluid (γ-ANPs; D ~ 20 nm; crystalline type) with the capability of strong colloidal dispersion at reservoir conditions, such as, high salinity, divalent ions (Ca2+) and high temperature was compared. The main goal of this research was to study the crude oil displacement mechanisms of alumina suspensions as a function of variety in size and particle morphology in aged carbonate rocks. The strong interaction potential between the particles was achieved by the citric acid and a special composition of a carboxylate-sulfonate-based polyelectrolyte polymer as an effective dispersant compound on the surface, leading to a negative particle charges and an additional steric and electrostatic repulsion. Wettability alteration upon exposure to fluids using the contact angle and the Amott cell were performed on saturated carbonate plug samples and rock slices. While, dynamic core displacements were conducted to test the water/nanofluid/oil flow and nanoparticle retention behavior thorough typical pore throats underground the reservoir conditions. The stability results revealed that PE-polymer was able to create a long-term colloidal fluid during 30 days. It was found that mass concentration of nanofluid increased with decreasing in particle size. The optimal amount of particles in aqueous solution was obtained 0.05 wt% for ANPs, increased up to 0.1 wt% for AQDs. Analysis of experiments showed that wettability alteration was the main mechanism during nanofluid injection. Laboratory core-flooding data proved that the enhanced oil recovery due to a less concentration state by ANPs was consistent with AQDs at higher concentrations. In addition, permeability-impairment-behavior study was discussed in terms of possible mineral scale deposition and alumina release on the rock surface. Results showed that a large extent of permeability damage caused by mineral scale (55-59%). Alumina quantum dot-based nanofluids were found a minimum impairment (2-4%) and a significant reduction of ~ 10% in permeability was observed for ANPs-based nanofluid.

Project description:Microbial Enhanced Oil Recovery (MEOR) is a promising strategy to improve recovery of residual oil in reservoirs, which can be performed by promoting specific indigenous microorganisms. In this study, we performed preliminary evaluation of the possibility of conducting MEOR at Mae Soon reservoir, an onshore reservoir in Northern Thailand. The reservoir's physicochemical characteristics, including the characteristics of the wells, the oil-bearing sandstone cores, and the reservoir's produced water, were determined. The microbiological characteristics of the oil wells in the reservoir were also investigated by submerging the reservoir's sandstone core samples, obtained from 6 oil wells, in the reservoir's produced water and in the produced water added with inorganic nutrients (KNO3 and NaH2PO4). The uncultured bacteria in both treatments were determined, using tagged 16S rRNA gene amplicon with Ion Torrent Sequencing Analysis. The effects of inorganic nutrients and the reservoir's parameters on the bacterial communities were analysed. A total number of 16,828 OTUs were taxonomically classified into 89 classes and 584 genera. In the controls (sandstone cores submerged in the produced water), the dominant bacterial populations were related to Deinococcus-Thermus, and Betaproteobacteria; while in the nutrient treated samples, there was a marked increase in the relative abundance of Gammaproteobacteria in three samples. Thermus, Acinetobacter, and Pseudomonas were the most abundant genera, and these are potential microorganisms for MEOR. Analysis of correlations between physiochemical properties of the reservoir and bacterial genera, using spearman's correlation analysis, suggested that some of the reservoir's properties, especially of the well and the rock, could influence some bacterial genera. To our knowledge, this is the first demonstration of the effect of inorganic nutrients on alteration of bacterial communities attached to reservoir's rock, and how the bacterial, physical, and chemical properties of a reservoir were co-analysed to serve as a basis for designing a MEOR process.

Dataset Information

Synergy of the flow behaviour and disperse phase of cellulose nanoparticles in enhancing oil recovery at reservoir condition.

Publications

Synergy of the flow behaviour and disperse phase of cellulose nanoparticles in enhancing oil recovery at reservoir condition.

Similar Datasets

OmicsDI is part of the ELIXIR infrastructure

Tweets