Assessing Green Methods for Pectin Extraction from Waste Orange Peels
Ontology highlight
ABSTRACT:
SUBMITTER: Benassi L
PROVIDER: S-EPMC8004147 | biostudies-literature |
REPOSITORIES: biostudies-literature
Similar Datasets
Project description:This is the first report on the extraction of cocoa bean shell (CBS) using deep eutectic solvents (DESs). Screening results with 16 different choline chloride-based DESs showed how choline chloride:oxalic acid DES was the most suitable solvent for the extraction of the bioactive compounds from CBS and that concentrations varied greatly depending on the used solvent. The DES extraction was compared to the DESs coupled with microwave extraction (MAE), and the yields of the extracted compounds were higher for DES/MAE. For theobromine, the obtained yields for DES extraction were 2.145-4.682 mg/g, and for caffeine, were 0.681-1.524 mg/g, whereas for DES/MAE, the same compounds were obtained in 2.502-5.004 mg/g and 0.778-1.599 mg/g. Antioxidant activity was also determined, using DPPH method, obtaining 24.027-74.805% activity for DES extraction and 11.751-55.444% for DES/MAE. Water content significantly influenced the extraction of targeted active compounds from CBS, whereas extraction time and temperature did not show statistically significant influence. The extraction temperature only influenced antioxidant activity. The study demonstrated how extraction using DES and microwaves could be of a great importance in the future trends of green chemistry for the production of CBS extracts rich in bioactive compounds.
| S-EPMC7073572 | biostudies-literature
Project description:Watermelon is the second largest fruit crop worldwide, with great potential to valorise its rind waste. An experimental design was used to model how extraction parameters (temperature, pH, and time) impact on the efficiency of the process, purity, esterification degree, monosaccharide composition and molar mass of watermelon rind pectin (WRP), with an insight on changes in their structural properties (linearity, branching degree and extraction severity). The models for all responses were accurately fitted (R2 > 90%, lack of fit p ≥ 0.05) and experimentally validated. At optimum yield conditions, WRP yield (13.4%), purity (540 µg/g galacturonic acid) and molar mass (106.1 kDa) were comparable to traditional pectin sources but showed a higher branching degree with longer galactan side chains and a higher protein interaction. Harsher conditions (pH 1) generated purer homogalacturonan fractions with average molar masses (80 kDa) at the expense of yield, while mild extraction conditions (pH ≥ 2) produced highly branched entangled pectin structures. This study underlines novel compositional features in WRP and the possibility of producing novel customized pectin ingredients with a wider potential application scope depending on the targeted structure.
| S-EPMC8066451 | biostudies-literature
Project description:In this work, a cascade approach to obtain different valuable fractions from lemon peels waste was optimised using microwave-assisted processes. Microwave-assisted hydrodistillation (MAHD) with a Clevenger apparatus was firstly used to obtain the lemon essential oil (LEO). The remaining residue was then submitted to microwave-assisted extraction (MAE) to extract the lemon pigment (LP). A Box-Behnken design was used to evaluate the influence of ethanol concentration, temperature and time in LP extraction in terms of extraction yield and colour intensity. Optimal extraction conditions for LP were 80% (v/v) ethanol, 80 °C and 50 min, with a liquid-to-solid ratio of 1:10. The obtained yields for LEO and LP were around 2 wt.% and 6 wt.%, respectively. The composition of LEO was analysed by gas chromatography with flame ionisation detection (GC-FID), and limonene (65.082 wt.%), β-pinene (14.517 wt.%) and γ-terpinene (9.743 wt.%) were mainly identified. LP was purified by using different Amberlite adsorption resins (XAD4, XAD7HP and XAD16N), showing XAD16N the best adsorption capacity. Enrichment factors of 4.3, 4.5 and 5.0 were found for eriocitrin, diosmin and hesperidin, respectively, which were detected as the main components in LP by ultra-high-performance liquid chromatography-diode array detector-tandem mass spectrometry (UPLC-DAD-MS) analysis, with final concentrations of 4.728 wt.%, 7.368 wt.% and 2.658 wt.%, respectively. Successful antimicrobial capacity against Escherichia coli and Staphylococcus aureus was obtained for LEO. The results from this work showed the potential of applying a cascading approach based on microwave-assisted processes to valorise lemon wastes, obtaining natural pigments and antimicrobials to be applied in food, cosmetic and polymer industries.
| S-EPMC7603390 | biostudies-literature
Project description:Brazilian biodiversity and favourable environmental conditions open up possibilities not yet explored, showing potential to shift the country's monochromatic economy into an emancipated, diversified and sustainable economic environment. This can be made possible through the integral use of its resources, exploring every functional fraction to create novel solutions to modern problems. Biorefineries present an interesting strategy to fully use the potential of agricultural feedstocks and together with green separation methods can contribute to the generation of sustainable processes and products. Passion Fruit (Passiflora edulis Sims f. flavicarpa Deg species) is produced on a large scale in Brazil and in other tropical countries, and its processing plants generate tons of residues that basically consist of peel, seeds and bagasse, which account for around 75% of its mass. These fractions of P. edulis can contain significant amounts of flavonoids, secondary metabolites that are the main compounds responsible for the fruit's bioactivity (antioxidant, anti-inflammatory, pesticide and biocide, in general). Therefore, this work aims to develop, apply and compare the best conditions for the extraction of isoorientin, orientin and isovitexin from passion fruit applying solid-liquid methodologies, followed by analyte quantification using UHPLC-PDA. Homogenizer-assisted (HAE), ultrasound-assisted (UAE) and microwave-assisted (MAE) extraction techniques were used, as well as a full factorial design to reach optimal parameters concerning the extraction yield and energy and solvent efficiencies. According to the results, the procedure based on HAE presented the best conditions for the extraction of selected flavonoids (1.07, 0.90 and 0.33 mg g-1 of isoorientin, orientin and isovitexin, respectively) and was considered the best method according to the green and sustainable described factors.
| S-EPMC7501698 | biostudies-literature
Project description:This study was conducted to improve the properties of thin films prepared from orange waste by the solution casting method. The main focus was the elimination of holes in the film structure by establishing better cohesion between the major cellulosic and pectin fractions. For this, a previously developed method was improved first by the addition of sugar to promote pectin gelling, then by the addition of maleic anhydride. Principally, maleic anhydride was introduced to the films to induce cross-linking within the film structure. The effects of concentrations of sugar and glycerol as plasticizers and maleic anhydride as a cross-linking agent on the film characteristics were studied. Maleic anhydride improved the structure, resulting in a uniform film, and morphology studies showed better adhesion between components. However, it did not act as a cross-linking agent, but rather as a compatibilizer. The middle level (0.78%) of maleic anhydride content resulted in the highest tensile strength (26.65 ± 3.20 MPa) at low (7%) glycerol and high (14%) sugar levels and the highest elongation (28.48% ± 4.34%) at high sugar and glycerol levels. To achieve a uniform film surface with no holes present, only the lowest (0.39%) level of maleic anhydride was necessary.
| S-EPMC6474150 | biostudies-other
Project description:Five new: 21,23-dihydro-21-hydroxy-23-oxonomilin (1), 21,23-dihydro-23-methoxy-21-oxonomilin (2), 21,23-dihydro-21-hydroxy-23-oxonomilinic acid methyl ester (3), 21,23-dihydro-23-methoxy-21-oxolimonin (4), and 21,23-dihydro-21-oxolimonin (5), and seven known limonoids were isolated from peels of satsuma orange (Citrus reticulata). The isolated compounds were evaluated for their inhibitory effects on macrophage activation by an inhibitory assay of nitric oxide (NO) production. Among them, compound (2) exhibited NO inhibitory activity without cytotoxicity.
| S-EPMC6152666 | biostudies-literature
Project description:Citrus fruits are extensively grown and much consumed around the world. Eighteen percent of total citrus cultivars are destined for industrial processes, and as a consequence, large amounts of waste are generated. Citrus waste is a potential source of high biological value compounds, which can be used in the food, pharmaceutical, and cosmetic industries but whose final disposal may pose a problem due to economic and environmental factors. At the same time, the emerging need to reduce the environmental impact of citrus waste and its responsible management has increased. For these reasons, the study of the use of non-conventional methods to extract high biological value compounds such as carotenoids, polyphenols, essential oils, and pectins from this type of waste has become more urgent in recent years. In this review, the effectiveness of technologies such as ultrasound assisted extraction, microwave assisted extraction, supercritical fluid extraction, pressurized water extraction, pulsed electric field, high-voltage electric discharges, and high hydrostatic pressures is described and assessed. A wide range of information concerning the principal non-conventional methods employed to obtain high-biological-value compounds from citrus waste as well as the most influencing factors about each technology are considered.
| S-EPMC7353614 | biostudies-literature
Project description:Carbon-based Fe?O? nanocomposites (C/Fe?O? NCs) were synthesized by a simple one-step hydrothermal method using waste pomelo peels as the carbon precursors. The characterization results showed that they had good structures and physicochemical properties. The prepared C/Fe?O? NCs could be applied as excellent and recyclable adsorbents for magnetic solid phase extraction (MSPE) of 11 triazole fungicides in fruit samples. In the MSPE procedure, several parameters including the amount of adsorbents, extraction time, the type and volume of desorption solvent, and desorption time were optimized in detail. Under the optimized conditions, the good linearity (R² > 0.9916), the limits of detection (LOD), and quantification (LOQ) were obtained in the range of 1?100, 0.12?0.55, and 0.39?1.85 μg/kg for 11 pesticides, respectively. Lastly, the proposed MSPE method was successfully applied to analyze triazole fungicides in real apple, pear, orange, peach, and banana samples with recoveries in the range of 82.1% to 109.9% and relative standard deviations (RSDs) below 8.4%. Therefore, the C/Fe?O? NCs based MSPE method has a great potential for isolating and pre-concentrating trace levels of triazole fungicides in fruits.
| S-EPMC5977316 | biostudies-literature
Project description:Carbon-based Fe₃O₄ nanocomposites (C/Fe₃O₄ NCs) were synthesized by a simple one-step hydrothermal method using waste pomelo peels as the carbon precursors. The characterization results showed that they had good structures and physicochemical properties. The prepared C/Fe₃O₄ NCs could be applied as excellent and recyclable adsorbents for magnetic solid phase extraction (MSPE) of 11 triazole fungicides in fruit samples. In the MSPE procedure, several parameters including the amount of adsorbents, extraction time, the type and volume of desorption solvent, and desorption time were optimized in detail. Under the optimized conditions, the good linearity (R² > 0.9916), the limits of detection (LOD), and quantification (LOQ) were obtained in the range of 1⁻100, 0.12⁻0.55, and 0.39⁻1.85 μg/kg for 11 pesticides, respectively. Lastly, the proposed MSPE method was successfully applied to analyze triazole fungicides in real apple, pear, orange, peach, and banana samples with recoveries in the range of 82.1% to 109.9% and relative standard deviations (RSDs) below 8.4%. Therefore, the C/Fe₃O₄ NCs based MSPE method has a great potential for isolating and pre-concentrating trace levels of triazole fungicides in fruits.
| S-EPMC5977316 | biostudies-literature
Project description:The impact of the DNA extraction methods on the gut bacterial and fungal microbiota community recovery
| PRJEB29363 | ENA