Microwave-assisted enzymatic hydrolysis to produce xylooligosaccharides from rice husk alkali-soluble arabinoxylan.
Ontology highlight
ABSTRACT:
SUBMITTER: Klangpetch W
PROVIDER: S-EPMC8741828 | biostudies-literature |
REPOSITORIES: biostudies-literature
Similar Datasets
Project description:The acid hydrolysis of saponins is commonly performed by conventional heating to produce sapogenin-rich products of bioactive interest, but alternative hydrolysis methods and their impact on bioactivity have been unexplored. We compared the conventional method with microwave-assisted acid hydrolysis (MAAH) of a commercial saponin-rich extract from a typical saponin source, fenugreek, focusing on the study of temperature (100, 120, 130, 140, 150 °C) and time (10, 20, 30, 40 min) of hydrolysis. The impact of these factors was assayed on both the sapogenin yield and the bioactivity of the hydrolyzed products, specifically their antioxidant and lipase inhibitory activities. The highest sapogenin content (34 g/100 g extract) was achieved by MAAH at 140 °C and 30 min, which was higher than conventional hydrolysis at both reference conditions (100 °C, 60 min, 24.6 g/100 g extract) and comparative conditions (140 °C, 30 min, 17 g/100 g extract) (p < 0.001). Typical steroid artifacts from sapogenins were observed in very small amounts, regardless of the method of hydrolysis. Antioxidant activity of MAAH hydrolyzed extracts (around 80% DPPH inhibition) was barely affected by time and temperature, but pancreatic lipase inhibitory activity was higher (>65%) at lower MAAH temperature (<130 °C) and time (<30 min) of hydrolysis. MAAH is shown as a valid alternative to produce selective sapogenin-rich extracts from fenugreek with minor impact on their bioactivities, and whose magnitude can be modulated by the hydrolysis conditions.
| S-EPMC9266256 | biostudies-literature
Project description:Microwave-assisted methanolysis was performed to fractionate a mixture of fatty acid methyl-esters from the cuticles of various wild plants and agricultural wastes. A combination of hydrothermal pretreatment and enzymatic hydrolysis effectively removed hemicellulose and cellulose to afford plant cuticles concentrated in residual materials. The subsequent methanolysis treatment afforded bio-oil from plant cuticles in ∼10% yield with a maximum higher heating value (HHV) of 32 MJ kg-1 from bagasse. The proposed cascading treatments allow the total use of herbaceous soft biomass by utilizing hemicellulose and cellulose fractions as well as plant cuticles to produce bio-oils with high HHVs.
| S-EPMC6562327 | biostudies-literature
Project description:Selective hydrolysis of polyamide-6 (PA-6) and polyamide-66 (PA-66) from commercial multicomponent PA-6/PA-66/polypropylene (PP) carpet is demonstrated by a microwave-assisted acid catalyzed hydrothermal process, yielding monomeric products and solid polypropylene residue. First, an effective method is established to chemically recycle neat PA-6 and PA-66 granules using microwave irradiation. The optimized, hydrochloric acid (HCl) catalyzed process leads to selective production of monomers, 6-aminocaproic acid or adipic acid and hexamethylenediamine, after only 30 min. A piece of commercial carpet is then recycled using the same reaction conditions, but with the alteration of the reaction time from 1 to 6 h. The produced water-soluble products and the remaining solid residue are carefully characterized, proving that the polyamide-part of the carpet is selectively hydrolyzed into water-soluble monomers and the polypropylene-part remains as an unconverted solid that can be further used to produce recycled filaments containing the carpet residue and virgin polypropylene. The developed process opens the possibility to recycle multicomponent materials, such as carpets, through selective hydrolysis. It can also contribute to a circular economy, producing original monomers and materials ready for a new life-cycle.
| S-EPMC8272014 | biostudies-literature
Project description:Edible insects have garnered increased interest as alternative protein sources due to the world's growing population. However, the allergenicity of specific insect proteins is a major concern for both industry and consumers. This preliminary study investigated the capacity of high hydrostatic pressure (HHP) coupled to enzymatic hydrolysis by Alcalase® or pepsin in order to improve the in vitro digestion of mealworm proteins, specifically allergenic proteins. Pressurization was applied as pretreatment before in vitro digestion or, simultaneously, during hydrolysis. The degree of hydrolysis was compared between the different treatments and a mass spectrometry-based proteomic method was used to determine the efficiency of allergenic protein hydrolysis. Only the Alcalase® hydrolysis under pressure improved the degree of hydrolysis of mealworm proteins. Moreover, the in vitro digestion of the main allergenic proteins was increased by pressurization conditions that were specifically coupled to pepsin hydrolysis. Consequently, HHP-assisted enzymatic hydrolysis represents an alternative strategy to conventional hydrolysis for generating a large amount of peptide originating from allergenic mealworm proteins, and for lowering their immunoreactivity, for food, nutraceutical, and pharmaceutical applications.
| S-EPMC7321092 | biostudies-literature
Project description:We report on a simple and efficient chemical recycling process for aliphatic polyamides (PA 66, PA 1010, PA 11, and PA 12), whereby PAs are converted exclusively into their constituent monomers even in the presence of reinforcement additives, such as carbon- and glass-fibers. In this process, the rate of PA hydrolysis reaction, performed under microwave irradiation in the presence of HCl as an acid catalyst, depends on the PA type, the HCl/amide mole ratio, and the type and amount of reinforcement additives. PA 66 is completely converted into the constituent monomers at 200 °C and a 1.25 HCl/amide mole ratio in 10 min. Long-chain PAs (PA 11, PA 12, and PA 1010) and PAs containing glass- or carbon-fiber reinforcement additives need at the same experimental conditions longer reaction times. Alternatively, they can be completely hydrolyzed at 200 °C within a comparable reaction time at a higher HCl/amide mole ratio of 2.5. Complete and straightforward conversion of PAs into the constituent monomers in the absence of side reactions simplifies the isolation and purification of monomers and reinforcement additives, which have been recovered in high yields and quality comparable to those of commercially available chemicals.
| S-EPMC7662757 | biostudies-literature
Project description:Enzymatic hydrolysis of sodium alginate to produce alginate oligosaccharides has drawn increasing attention due to its advantages of containing a wild reaction condition, excellent gel properties and specific products easy for purification. However, the efficient commercial enzyme tools are rarely available. A new alginate lyase with high activity (24,038 U/mg) has been purified from a newly isolated marine strain, Cellulophaga sp. NJ-1. The enzyme was most active at 50 °C and pH 8.0 and maintained stability at a broad pH range (6.0-10.0) and temperature below 40 °C. It had broad substrate specificity toward sodium alginate, heteropolymeric MG blocks (polyMG), homopolymeric M blocks (polyM) and homopolymeric G blocks (polyG), and possessed higher affinity toward polyG (15.63 mM) as well as polyMG (23.90 mM) than polyM (53.61 mM) and sodium alginate (27.21 mM). The TLC and MS spectroscopy analysis of degradation products suggested that it completely hydrolyzed sodium alginate into oligosaccharides of low degrees of polymerization (DPs). The excellent properties would make it a promising tool for full use of sodium alginate to produce oligosaccharides.
| S-EPMC4926067 | biostudies-literature
Project description:The present study was focused on the preparation and characterization of the antioxidant peptides by microwave-assisted enzymatic hydrolysis of collagen from sea cucumber Acaudina molpadioides (ASC-Am) obtained from Zhejiang Province in China. The results exhibited the effects of microwave irradiation on hydrolysis of ASC-Am with different protease. Neutrase was selected from the four common proteases (papain, pepsin, trypsin, and neutrase) based on the highest content and DPPH scavenging activity of hydrolysate Fa (Molecular weight < 1 kDa). The content and 2,2-diphenyl-1-picrylhydrazyl (DPPH) scavenging activity of Fa obtained by hydrolysis of neutrase increased by 100% and 109% respectively at a microwave power of 300 W compared with no microwave irradiation. Five subfractions were obtained after performing the gel filtration chromatography, and the Fa.2 exhibited the highest DPPH scavenging activity. The amino acid analysis showed that the contents of Glutamic acid, Alanine, Tyrosine, and Phenylalanine in fraction Fa.2 increased significantly, but an obvious decrease in the content of Glycine was observed compared to Fa. Four peptides (Fa.2-A, Fa.2-B, Fa.2-C, and Fa.2-D) were purified from Fa.2 by high performance liquid chromatography, and Fa.2-C showed the highest DPPH scavenging activity. The sequence of Fa.2-C was identified as Phenylalanine-Leucine- Alanine-Proline with a half elimination ratio (EC50) of 0.385 mg/mL. The antioxidant activity of Fa.2-C was probably attributed to the small molecular sizes and the presence of hydrophobic amino acid residues in its sequence. This report provided a promising method for the preparation of antioxidant peptides from collagen for food and medicinal purposes.
| S-EPMC6471976 | biostudies-literature
Project description:This study presents on-tissue proteolytic digestion using a microwave irradiation and peptide extraction method for in situ analysis of proteins from spatially defined regions of a tissue section. The methodology utilizes hydrogel discs (1 mm diameter) embedded with trypsin solution. The enzyme-laced hydrogel discs are applied to a tissue section, directing enzymatic digestion to a spatially confined area of the tissue. By applying microwave radiation, protein digestion is performed in 2 min on-tissue, and the extracted peptides are then analyzed by matrix assisted laser desorption/ionization mass spectrometry (MALDI MS) and liquid chromatography tandem mass spectrometry (LC-MS/MS). The reliability and reproducibility of the microwave assisted hydrogel mediated on-tissue digestion is demonstrated by the comparison with other on-tissue digestion strategies, including comparisons with conventional heating and in-solution digestion. LC-MS/MS data were evaluated considering the number of identified proteins as well as the number of protein groups and distinct peptides. The results of this study demonstrate that rapid and reliable protein digestion can be performed on a single thin tissue section while preserving the relationship between the molecular information obtained and the tissue architecture, and the resulting peptides can be extracted in sufficient abundance to permit analysis using LC-MS/MS. This approach will be most useful for samples that have limited availability but are needed for multiple analyses, especially for the correlation of proteomics data with histology and immunohistochemistry.
| S-EPMC4287167 | biostudies-literature
Project description:Grain stillage from the liquor industry was pretreated by using microwave-assisted hydrothermal pretreatment, fungal pretreatments, and their combination to enable efficient enzymatic hydrolysis for sugar production. The microwave-assisted hydrothermal (MH) pretreatment was optimized by using a response surface methodology, and the respective maximum reducing sugar yield and saccharification efficiency of 17.59 g/100 g and 33.85%, respectively, were achieved under the pretreatment conditions of microwave power = 120 W, solid-to-liquid ratio = 1:15 (g·mL-1), and time = 3.5 min. The fungal pretreatment with Phanerochaete chrysosporium digestion (PC) achieved the maximum ligninolytic enzyme activities in 6 days with 10% inoculum size at which the reducing sugar yield and saccharification efficiency reached 19.74 g/100 g and 36.29%, respectively. To further improve the pretreatment efficiency, MH and PC pretreatments were combined, but the sequence of MH and PC mattered on the saccharification efficiency. The MH + PC pretreatment (the MH prior to the PC) was better than PC + MH (the PC prior to the MH) in terms of saccharification efficiency. Overall, the MH + PC pretreatment achieved superior reducing sugar yield and saccharification efficiency (25.51 g/100 g and 66.28%, respectively) over all other studied pretreatment methods. The variations of chemical compositions and structure features of the raw and pretreated grain stillage were characterized by using scanning electron microscopy and Fourier transform infrared spectroscopy. The results reveal that both MH and PC pretreatments mainly functioned on delignification and decreasing cellulose crystallinity, thus enhancing the enzymatic saccharification of the pretreated grain stillage. The combined MH and PC pretreatment could be a promising method to enable cost-efficient grain stillage utilization for downstream applications such as biofuels.
| S-EPMC7288354 | biostudies-literature
Project description:Removing alkali-soluble lignin using extractive ammonia (EA) pretreatment of corn stover (CS) is known to improve biomass conversion efficiency during enzymatic hydrolysis. In this study, we investigated the effect of alkali-soluble lignin on six purified core glycosyl hydrolases and their enzyme synergies, adopting 31 enzyme combinations derived by a five-component simplex centroid model, during EA-CS hydrolysis. Hydrolysis experiment was carried out using EA-CS(-) (approx. 40% lignin removed during EA pretreatment) and EA-CS(+) (where no lignin was extracted). Enzymatic hydrolysis experiments were done at three different enzyme mass loadings (7.5, 15 and 30?mg protein?g-1 glucan), using a previously developed high-throughput microplate-based protocol, and the sugar yields of glucose and xylose were detected. The optimal enzyme combinations (based on % protein mass loading) of six core glycosyl hydrolases for EA-CS(-) and EA-CS(+) were determined that gave high sugar conversion. The inhibition of lignin on optimal enzyme ratios was studied, by adding fixed amount of alkali-soluble lignin fractions to EA-CS(-), and pure Avicel, beechwood xylan and evaluating their sugar conversion. The optimal enzyme ratios that gave higher sugar conversion for EA-CS(-) were CBH I: 27.2-28.2%, CBH II: 18.2-22.2%, EG I: 29.2-34.3%, EX: 9.0-14.1%, ?X: 7.2-10.2%, ?G: 1.0-5.0% (at 7.5-30?mg?g-1 protein mass loading). Endoglucanase was inhibited to a greater extent than other core cellulases and xylanases by lignin during enzyme hydrolysis. We also found that alkali-soluble lignin inhibits cellulase more strongly than hemicellulase during the course of enzyme hydrolysis.
| S-EPMC6030313 | biostudies-literature